Abstract
A biofilter treating alkylbenzene vapors was characterized for its optimal running conditions and kinetic parame-ters. Kinetics of the continuous biofilter were compared to batch kinetic data obtained with biofilm samples as well as with defined microbial consortia and with pure culture isolates from the biofilter. Both bacteria and fungi were present in the bioreactor. Five strains were isolated. Two bacteria, Bacillus and Pseudomonas, were shown to be dominant, as well as a Trichosporon strain which could, however, hardly grow on alkylbenzenes in pure culture. The remaining two strains were most often overgrown by the other three organisms in liquid phase batch cultures μ max, KS, KI values and biodegradation rates were calculated and compared for the difterent mixed and pure cultures. Since filter bed acidification was observed during biofiltration studies reaching a pH of about 4, experiments were also undertaken to study the influence of pH on performance of the different cultures. Biodegradation and growth were possible in all cases, over the pH range 3.5–7.0 at appreciable rates, both with mixed cultures and with pure bacterial cultures. Under certain conditions, microbial activity was even observed in the presence of alkylbenzenes down to pH 2.5 with mixed cultures, which is quite unusual and explains the ability of the present biocatalyst to remove alkylbenzenes with high efficiency in biofilters under acidic conditions.
Similar content being viewed by others
References
Alonso C, Sudan MT, Sorial GA, Smith FL, Biswas P, Smith PJ & Brenner RC (1997) Gas treatment in trickle-bed biofilters biomass, how much is enough? Biotechnol. Bioeng. 54: 583–594.
Alvarez PJJ & Vogel TM (1991) Substrate interactions of benzene, toluene, and para-xylene during microbial degradation by pure cultures and mixed culture aquifier slurries. Appl. Environ. Microbiol. 57: 2981–2985
Andrews JF (1968) A mathematical model for the continuous culture of microorganisms utilizing inhibitory substrates. Biotechnol. Boeng. 10: 707–723
Arcangeli JP & Arvin E (1992) Toluene biodegradation and biofilm growth in an aerobic fixed-film reactor. Appl. Microbiol. Biotechnol. 37: 510–517
Chang M-K, Voice TM & Criddle CS (1993) Kinetics of competitive inhibition and cometabolism in the biodegradation of benzene, toluene, and p-xylene by two Pseudomonas isolates. Biotechnol. Bioeng. 41: 1057–1065
Choi Y-B, Lee J-Y & Kim H-S (1992) A novel bioreactor for the biodegradation of inhibitory aromatic solvents: experimental results and mathematical analysis. Biotechnol. Bioeng. 40: 1403–1411
Cox HHJ, Doddema HJ & Harder W (1994) Biological removal of styrene from waste gases using fungi on inert support materials. VDI Berichte 1104: 289–299
Elmén J, Pan W, Leung SY, Magyarosy A & Keasling JD (1997) Kinetics of toluene degradation by a nitrate-reducing bacterium isolated from a groundwater aquifer. Biotechnol. Bioeng. 55: 82–90
Ergas SJ, Kinney K, Fuller ME & Scow KM (1994) Characterization of a compost biofiltration system degrading dichloromethane. Biotechnol. Boeng. 44: 1048–1054
Ergas SJ, Schroeder ED, Chang DPY & Morton RL (1995) Control of volatile organic compound emissions using a compost biofilter. Water Environ. Res. 67: 816–821
Fritsche K & Lechner U (1992) Einsatz eines chlorphenolverwertenden Bakterienstammes zur Abluftreinigung im Biofilter. In: Dragt AJ & van Ham J (Eds) Biotechniques for Air Pollution Abatement and Odour Control Policies, (pp 287–292). Elsevier, Amsterdam
Haldane JBS (1930) Enzymes. Longmans, London
Holubar P & Braun R (1995) Biofiltration — bottlenecks in biological air purification and possible future solutions. Med. Fac. Landbouww. Gent. 60: 2303–2312
Kennes C, Cox H, Veiga MC & Doddema W (1995) Continuous removal of benzene related compounds from waste gases. Med. Fac. Landbouww. Gent. 60: 2279–2284
Kennes C, Cox HHJ, Doddema HJ & Harder W (1996) Design and performance of biofilters for the treatment of alkylbenzene vapors. J. Chem. Technol. Biotechnol. 66: 300–304
Kennes C & Thalasso F (1998) Waste gas biotreatment technology. J. Chem. Technol. Biotechnol. 72: 303–319
Leson G & Winer AM (1991) Biofiltration: An innovative air pollution control technology for VOC emissions. J. Air Waste Manag. Assoc. 41: 1045–1054
Mirpuri R, Jones W, Bryers JD (1997) Toluene degradation kinetics for planktonic and biofilm-grown cells of Pseudomonas putida 54G. Biotechnol. Bioeng. 53: 535–546
Páca J & Koutský B (1994) Performance characteristics of a biofilter during xylene and toluene degradation. Med. Fac. Landbouww. Gent. 59: 2175–2184
Pedersen AR, Moller S, Molin S & Arvin E (1997) Activity of toluene-degrading Pseudomonas putida in the early growth phase of a biofilm for waste gas treatment. Biotechnol. Bioeng. 54: 131–141
Smith MR (1990) The biodegradation of aromatic hydrocarbons by bacteria. Biodegradation. 1: 91–206
Van Groenestijn JW & Hesselink PGM (1993) Biotechniques for air pollution control. Biodegradation 4: 283–301
Veiga MC, Fraga M, Amor L & Kennes C (1997) Microbial and kinetic characterization of biofilters degrading alkylbenzene vapors under acidic conditions. In: Verachtert H & Verstraete W (Eds) International Symposium Environmental Biotechnology (pp 185–188). TIV, Oostende, Belgium
Veir JK, Schroeder ED, Chang DPY & Scow KM (1996) Interaction between toluene and dichloromethane degrading populations in a compost biofilter. 89th Annual Meeting and Exhibition Air and Waste Management Association, Nashville, USA
Wübker S-M, Laurenzis A, Werner U & Friedrich C (1997) Controlled biomass formation and kinetics of toluene degradation in a bioscrubber and in a reactor with a periodically moved trickle-bed. Biolechnol. Bioeng. 55: 686–692
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Veiga, M.C., Fraga, M., Amor, L. et al. Biofilter performance and characterization of a biocatalyst degrading alkylbenzene gases. Biodegradation 10, 169–176 (1999). https://doi.org/10.1023/A:1008301415192
Issue Date:
DOI: https://doi.org/10.1023/A:1008301415192