Skip to main content

Advertisement

Log in

Propylene glycol monomethyl ether occupational exposure. 3. Exposure of human volunteers

  • Original Article
  • Published:
International Archives of Occupational and Environmental Health Aims and scope Submit manuscript

Abstract

Objective: Propylene glycol monomethyl ether (PGME) is a widely used additive in industrial and consumer products (paints, inks, diluents, cleaning products, cosmetics...). The aim of the present study was to determine uptake and disposition of PGME α-isomer in humans. Method: Six healthy male volunteers were exposed to PGME-α vapour (15, 50 and 95 ppm) with and without respiratory protection for 6 h including a 30-min break. Free PGME and total PGME (free and conjugated) were analysed in urine. The analytical method involved hydrolysis with HCl (only for the analysis of total PGME in urine), a solid phase extraction on LC-18 columns and a gas chromatograph-flame ionisation detector (GC/FID) analysis after derivatisation with trimethylsilylimidazole. Results: End-exposure levels of free PGME in urine were found to reach 1.3 (±0.3), 4.4 (±1.6) and 7.9 (±2.5) mg/l for 15, 50 and 95-ppm exposure, respectively, without respiratory protection. End-exposure levels of total PGME in urine were found to reach 2.5 (±0.8), 6.2 (±1.6) and 10.3 (±2.3) mg/l for 15, 50 and 95-ppm exposure respectively. Levels of free PGME were also monitored in exhaled air (0.4 (±0.1), 1.4 (±0.4) and 2.9 (±0.9) ppm at the end of 15, 50 and 95-ppm exposure, respectively) and in blood (2.0 (±0.9), 4.9 (±2.3) and 11.8 (±2.4) mg/l at the end of 15, 50 and 95-ppm exposure, respectively). PGME is rapidly excreted in urine and in exhaled air; the half-lives were calculated to be approximately 3.5 h in urine and 10 min in exhaled air. PGME was below detection limits in breath (<0.1 ppm), in blood (<1 mg/l) and in urine (<1 mg/l) after dermal-only exposure to vapour. Conclusions: This study has demonstrated the relatively high pulmonary uptake compared with the dermal uptake. It has also shown the rapid excretion in urine (3.5 h) and in expired air (10 min). With regard to metabolism, this study has established the presence of conjugated PGME in urine.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Anne Devanthéry.

Additional information

Electronic Publication

Rights and permissions

Reprints and permissions

About this article

Cite this article

Devanthéry, A., Berode, M. & Droz, PO. Propylene glycol monomethyl ether occupational exposure. 3. Exposure of human volunteers. IAOEH 75, 203–208 (2002). https://doi.org/10.1007/s00420-001-0310-4

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00420-001-0310-4

Navigation