Abstract
The electrical conductivity of carbon black filled ethylene-vinyl acetate copolymer was measured as a function of carbon and vinyl acetate (VAc) content. For the composites whose matrices contain less than 32 wt% ofVAc content, a sharp break point of the relation between carbon content and conductivity was observed. The conductivity jumps as much as ten orders of magnitude at the break point. The critical carbon content corresponding to the break point can essentially be predicted by our previous model. This model was derived under certain assumptions, the most important of which is that when the interfacial excess energy introduced by carbon particles into the polymer matrix reaches a “universal value”,Δg *, the carbon particles begin to coagulate so as to avoid any further increase of energy and to form networks which facilitate electrical conduction. On the other hand, for the composites whose matrices contain more than 32 wt% ofVAc content, a sharp break of the relation between the carbon content and conductivity cannot be observed and conductivity increases continuously with increasingVAc content. In this region ofVAc content, carbon particles were dispersed well in theVAc rich matrices. This is because the presence of polar groups in aVAc component enhances its bonding to conductive fillers. In this case, the interfacial excess energy,Δg, seems to be the caseΔg≤0. Better dispersibility of fillers in this region ofVAc content can be shown from an electron micrograph (TEM).
Similar content being viewed by others
References
Garland J (1966) Trans Met Soc AIME 236:642
Malliaris A, Turner DT (1972) J Appl Phys 42:614
Buche F (1972) ibid 43:4837
Aharoni SM (1972) ibid 43:2463
Kusy RP, Turner DT (1973) J Appl Polym Sci 17:1631
Buche F (1973) J Appl Phys 44:532
Sacrisbrick RM (1973) J Phys D 6:2098
Pike GE, Seager CH (1974) Phys Rev B10:1421
Seager CH, Pike GE (1974) ibid 10:1435
Mukhopadhyay R, De SK, Basu S (1976) J Appl Polym Sci 20:2575
Verhelst WF, Wolthuis KG, Voet A, Ehrburger P, Donnet JB (1977) Rubber Chem Tech 50:735
Sircar AK, Lamond TG (1978) ibid 51:126
Matsushita R, Senna M, Kuno H (1977) J Mater Sci 12:509
Grekila RB, Tien TY (1965) J Amer Ceram Soc 48:22
Flory PJ (1953) Principles of Polymer Chemistry, Chapter 9, Cornell University Press
Miyasaka K, Watanabe K, Jojima E, Aida H, Sumita M, Ishikawa K (1982) J Mater Sci 17:1610
Wiliams ML, Landel RF, Ferry J (1955) J Amer Chem Soc, 77:3701
Fowkes FM (1964) Ind Eng Chem 56:40
Hata T, Hyomen (1968) [Surface, Japan] 6:659
Wu S (1982) Polymer Interface and Adhesion, Marcel Dekker Inc, New York, Chapter 3:107
Sumita M, Abe H, Kayaki H, Miyasaka K (1986) J Macromol Sci Phys B25:171
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Sumita, M., Asai, S., Miyadera, N. et al. Electrical conductivity of carbon black filled ethylene-vinyl acetate copolymer as a function of vinyl acetate content. Colloid & Polymer Sci 264, 212–217 (1986). https://doi.org/10.1007/BF01414955
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF01414955