Mass spectrometry identification of the liquor contained in the plum vase excavated from Jurou Li’s Grave of the Jin Dynasty (1115–1234 CE) in Xi’an, Shannxi, China

Abstract

In order to accurately identify the ancient liquid contained in the plum vase excavated from Jurou Li’s Grave of the Jin Dynasty (1115–1234 CE) in Xi’an, mass spectrometry was applied to determine the amino acid sequences of the residual proteins extracted from the liquid sample. The sequences were searched against a standard protein sequence database. The proteins extracted was identified as glycosyltransferase from Sorghum bicolor, calcium-dependent protein kinase 2 from Wickerhamomyces ciferrii, and cytochrome b-c1 complex subunit Rieske from Nadsonia fulvescens. These findings indicate that the extremely degraded liquid in the plum vase was made from the cereal of sorghum by alcoholic fermentation of Wickerhamomyces ciferrii and Nadsonia fulvescens, providing direct evidence for liquor in the Jin Dynasty.

Introduction

In February 2014, an undisturbed grave with one brick chamber was excavated by Shannxi Provincial Institute of Archaeology [1]. According to the inscription on the unearthed brick tablet, the owner of in the grave is Jurou Li, the highest official of Shannxi province in the Jin Dynasty (1115–1234 CE). A total of 64 objects, including porcelain, bronze, jade etc. were discovered. The most important object among them is a plum vase which has been sealed completely, containing transparent liquid (see Fig. 1).

Fig. 1

The plum vase excavated from Jurou Li’s Grave of the Jin Dynasty (1115–1234 CE)

Plum vase is a general designation of ancient Chinese porcelain with the features of small rim, short neck, broad shoulder, thin base, ringed foot. It is named as the rim is so small that only plum twigs could be inserted in, and it is well-known as a container for liquor [2, 3]. Thus, it is logically consistent to develop a working hypothesis that the liquid contained in the excavated plum vase was liquor from the Jin Dynasty.

To the best of the authors’ knowledge, Chinese liquor is defined as fermented beverage with cereals as raw materials. Hence, the information about both raw material and fermentation is required to determine whether an ancient liquid is liquor or not. It was shown that through chemical, archaeobotanical, DNA analysis of residues, it is possible to understand the original content of ancient fermented beverage [4,5,6,7,8,9,10,11,12,13,14,15,16,17,18,19,20]. Nevertheless, due to disparate preservation conditions of samples from different archaeological background, it is promising to explore the degraded residues of proteins from plants and yeasts related to liquor-making by mass spectrometry, when conventional analytical methods are not applicable.

In this paper, the residual peptides from ancient liquid in the plum vase excavated from Jurou Li’s Grave was focused on, as the analyses of small molecules and starch grain did not yield satisfactory results. To recognize the raw material and possible fermentation of the liquid, we applied SDS-PAGE to isolate possible proteins and identified them by means of mass spectrometry.

Materials and methods

Chemicals and reagents

1.4-Dithiothreitol (DTT) was obtained from Amresco (USA). Acetonitrile (ACN) was acquired from Fisher (USA). Trifluoroacetic acid (TFA), iodoacetamide, ammonium bicarbonate, and formic acid were supplied by Sigma-Aldrich (USA). Trypsin was purchased from Promega (USA). Deionized water was provided by a Milli-Q Ultrapure water purification system (USA). Vivaspin 500 ultrafiltration devices (3 kDa MWCO) were purchased from GE Healthcare (USA).

SDS-PAGE

100 μL of liquid was pipetted from the plum vase, desalted and concentrated to 20 μL using an ultrafiltration device. Then it was mixed directly with 5 μL of SDS-PAGE loading buffer. Sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE) was performed on a continuous buffered system using a precast gel (4–20%). Before electrophoresis, the sample was heated for 5 min in boiling water. 20 μL of sample was applied to the lane. After completion of an electrophoresis run at 150 V for 45 min, the gel was removed from the glass plate and stained with 0.25% Coomassie Brilliant Blue (R-250) for 4 h, and destained with aqueous solution containing 30% methanol and 10% acetic acid for 24 h.

In-gel digestion

The blue-stained area on the gel was cut into small spots of 1 mm [2], destained with 25 mM NH₄HCO₃ and 50% acetonitrile for two times separately (1 h per time), and dehydrated by the addition of 500 μL acetonitrile (100%). Disulfide bonds were cleaved by incubating the sample for 60 min at 56 °C with 200 μL DTT (10 mM) in 25 mM NH₄HCO₃ buffer. Then alkylation of cysteines was performed by incubation of the sample with 200 μL iodoacetamide (55 mM) in 25 mM NH₄HCO₃ buffer for 45 min at room temperature in darkness. And then spots were dehydrated again with 500 μL of acetonitrile after washed by 25 mM NH₄HCO₃ twice. After that, trypsin solution (10 ng/μL in 25 mM NH₄HCO₃ buffer) was added for 37 °C overnight digestion which was stopped by addition of 5% formic acid. Finally, the extracts were dried under the protection of N₂, and reconstituted in 3 μL of 0.1% trifluoroacetic acid prior to mass spectrometry analysis.

LC-ESI-MS/MS analysis based on Orbitrap

After protein digestion, the peptide sample was desalted using a Strata X column (Phenomenex), vacuum-dried and then resuspended in 200 μL buffer A (2% ACN, 0.1% FA). After centrifugation at 20,000g for 10 min, the supernatant was recovered to obtain a peptide solution with a final concentration of approximately 0.5 μg/μL. 10 μL supernatant was loaded on a LC-20AD nano HPLC (Shimadzu, Japan) by the autosampler onto a 2 cm C18 trap column. Then, the peptides were eluted onto a 10 cm analytical C18 column (inner diameter 75 μm) packed in-house. The sample was loaded at 15 μL/min for 4 min, then the 91 min gradient was run at 400 nL/min starting from 2 to 35% buffer B (98% ACN, 0.1% FA), followed by 5 min linear gradient to 80%, and maintenance at 80% B for 8 min, and finally return to 2% in 2 min.

The peptides were subjected to nanoelectrospray ionization followed by tandem mass spectrometry (MS/MS) in an LTQ Orbitrap Velos (Thermo Fisher Scientific, USA) coupled online to the HPLC. Intact peptides were detected in the Orbitrap at a resolution of 60,000. Peptides were selected for MS/MS using collision induced dissociation (CID) operating mode with a normalized collision energy setting of 35%. Ion fragments were detected in the LTQ. A data-dependent procedure that alternated between 1 MS scan followed by 10 MS/MS scans was applied for the ten most abundant precursor ions above a threshold ion count of 5000 in the MS survey scan with a following dynamic exclusion settings: repeat counts of 2, repeat duration of 30 s, and exclusion duration of 120 s. The applied electrospray voltage was 1.5 kV. Automatic gain control (AGC) was used to prevent overfilling of the ion trap. 1 × 10⁴ ions were accumulated in the ion trap to generate CID spectra. For MS scans, the m/z scan range was 350–2000 Da.

Database search

Raw data from nano LC-MS/MS analysis was searched against the non-redundant protein database (Uniprot, with Spermatophyta and Fungi as taxonomy restriction) using in-house MASCOT software version 2.3.02 (Matrix Science, USA). Trypsin was chosen as cleavage specificity with a maximum number of allowed missed cleavages of two. Carbamidomethylation (C) was set as a fixed modification, while deamidation (NQ), oxidation (M) and Gln→pyro-Glu (N-term Q) as variable modifications. The searches were performed using a peptide mass tolerance of 20 ppm and a fragment mass tolerance of 0.1 Da. To determine if a reanalysis step is needed, quality control was performed and the MASCOT e-value was set to below 0.05. Protein identifications were accepted with at least one unique peptide. All the identified peptides were extracted and BLAST searched against the NCBInr database to check the species-specificity of the sequences.

Results and discussion

The liquid sample recovered from the plum vase excavated from Jurou Li’s Grave was analyzed with the scope of assessing its nature. In our sample, severe deterioration of the content was expected considering the nearly one millennium age of the sample and the critical storage conditions during the amazingly long period in the grave. Chromatography testing of this sample was unsuccessful in determining whether this was liquor, because small molecules such as ethanol, other alcohols and esters have faded away due to their volatility. Trace of degraded residues of proteins has the potential to survive and provide key information for the ancient liquid.

The proposed methodology was based on the capability of mass spectrometry to detect species-specific peptides from proteins, for the objective to identify the origin species of the proteins from ancient and denaturated sample of the liquid contained in the plum vase. It is shown in Fig. 2 that the extraction protocol used here was effective in recovering enough residues of proteins representing the nature of the liquid. However, the weak staining and obvious smearing of the bands along the gel indicated that the protein preserved in the ancient liquid was infinitesimal and highly degraded.

Fig. 2

SDS-PAGE profile of the extracted proteins from the liquid contained in the plum vase

The mass spectrometric approach to properly identify proteins requires that sequences of at least one peptide is determined regardless of the integrity of the full protein. It is presented in Table 1 that three unique peptides were identified from the degraded residues, in which one for Sorghum bicolor glycosyltransferase (SORBI_3001G093100), one for Nadsonia fulvescens cytochrome b-c1 complex subunit Rieske (NADFUDRAFT_81912), and one for Wickerhamomyces ciferrii calcium-dependent protein kinase 2 (BN7_3818).

Table 1 Species unique peptides of proteins identified for the liquid sample analyzed

The analysis of an extra low content of this ancient sample resulted in a set of ions with good signal-to-noise ratio. Particularly, the MS/MS spectra shown respectively in Figs. 3, 4 and 5 allowed the identification of the peptide AGELAERAR in the glycosyltransferase from Sorghum bicolor, peptide SISISGLR in the cytochrome b-c1 complex subunit Rieske from Nadsonia fulvescens, and peptide IILDVK in the calcium-dependent protein kinase 2 from Wickerhamomyces ciferrii. The data is reliable since the y and b ions had good continuity.

Fig. 3

MS/MS spectrum of the doubly charged ion at m/z = 486.759 from the digested extract of the liquid sample from the plum vase and presenting the y and b fragments of the peptide sequence AGELAERAR specific to the glycosyltransferase from Sorghum bicolor

Fig. 4

MS/MS spectrum of the doubly charged ion at m/z = 416.748 from the digested extract of the liquid sample from the plum vase and presenting the y and b fragments of the peptide sequence SISISGLR specific to the cytochrome b-c1 complex subunit Rieske from Nadsonia fulvescens

Fig. 5

MS/MS spectrum of the doubly charged ion at m/z = 350.734 from the digested extract of the liquid sample from the plum vase and presenting the y and b fragments of the peptide sequence IILDVK specific to the calcium-dependent protein kinase 2 from Wickerhamomyces ciferrii

In contrast to occidental tradition of wine-making, Chinese liquor is characterized by using cereals as raw materials including sorghum, barley, wheat, rice, and pea. Among them, Sorghum bicolor was considered as the optimal one [21]. Glycosyltransferase (GT) is ubiquitous in plant cells, transfers nucleotide-diphosphate-activated sugars to low molecular weight substrates [22].

Starch grain extraction and analysis was attempted and showed no relevant result because the micro remains of plants failed to preserve during the long period. The accurate identification of glycosyltransferase from Sorghum bicolor by mass spectrometry indicated that the liquid contained in the plum vase was probably beverage made from Sorghum bicolor.

Yeasts play a significant role in liquor making, as they are the key to alcoholic fermentation. It has been reported that both Wickerhamomyces ciferrii and Nadsonia fulvescens are good candidates for alcoholic fermentation, with the ability to produce by-products of aromas and fusel alcohols [23,24,25]. Furthermore, Wickerhamomyces ciferrii was identified in a traditional rice wine in India [26]. The evidence of both yeast and cereal proteins existed in the sample converge to support the hypothesis that the liquid contained in the plum vase was indeed ancient liquor. In detail, fermentation of Sorghum bicolor cereal by mediation of Wickerhamomyces ciferrii and Nadsonia fulvescens can be inferred.

How many peptides could represent a reliable identification of a protein? It is still an open question concerning the guidelines for peptide and protein identification data [27]. Recent publication in top journals on proteomics showed that proteins could be unequivocally identified with at least one unique peptide [28, 29]. Since the sample in this work is extremely degraded in archaeological context, adopting the above threshold could reveal more solid information. The plum vase containing the liquid sample was intactly sealed, reducing the probability of contamination. Moreover, ancient literature recorded that porcelain of this style tended to be used for storage of liquor [30,31,32]. Therefore, despite the low amount of sample analyzed, the developed methodology succeeded in identifying the liquor contained in the excavated plum vase.

Conclusions

Plum vase is a prevalent style of vessel among all strata since the Tang Dynasty (618–907 CE). It was successfully demonstrated that the one excavated from Jurou Li’s Grave of the Jin Dynasty was used for liquor storage. This study constitutes the first accurate identification of the liquid contained in excavated plum vase, reveals key information about the raw material and fermentation of the ancient Chinese liquor, provides scientific basis for the function of plum vase. Also, it is shown that the adopted technical process was efficient in regarding accurate identification of the origin species of cereal and yeast in liquor-making from complex matrix containing very low amounts of residues.