Skip to main content
SpringerLink
Log in

Removal of arsenic from water by an iron-loaded resin prepared from Pinus pinaster bark tannins

  • Original Paper
  • Published:
Euro-Mediterranean Journal for Environmental Integration Aims and scope Submit manuscript

Abstract

Arsenic is a toxic and carcinogenic metalloid naturally present in water bodies. However, its concentration can be exacerbated by anthropogenic activities (e.g. mining, industry, agriculture). Thus, removal of arsenic from contaminated waters is a crucially important goal. Tannins are ubiquitous and inexpensive natural biopolymers that are easy to extract and convert into insoluble matrices. The aim of this work was to assess the potential of Pinus pinaster bark tannin resins to take up arsenic from aqueous solutions. Methods of tannin extraction and polymerization, oxidation and iron-loading were optimized. An extraction efficiency of 24.2 ± 0.1% was achieved and 166 ± 2 mg of formaldehyde-condensable phenols were extracted per gram of bark used. Polymerization of tannins, under the best conditions, presented an efficiency around 80%. Oxidation and iron loading yielded a tannin resin with an iron content of approx. 20 mg g–1. Adsorption of As(V) was optimal at pH 3 with a removal of approx. 90% from an initial solution containing 5 mg L–1. Adsorption assays with As(III) presented negligible results. As(V) adsorption was somewhat fast, with equilibrium being achieved in 1–4 h. Equilibrium data obtained for As(V) adsorption showed a maximum adsorption capacity of 0.72 ± 0.03 mg g–1 (pH 3, smaller than 150 µm). Iron leaching was high at low pH but could be drastically reduced by limiting the contact time. This work attempts to show that a forest residue, usually undervalued, can be converted into an adsorbent and can help in dealing with arsenic-contaminated waters, which is an environmental problem affecting many countries in the world.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8

Similar content being viewed by others

References

  • Alvares Rodrigues L, Koibuchi Sakane K, Alves Nunes Simonetti E, Patrocínio Thim G (2015) Cr total removal in aqueous solution by PHENOTAN AP based tannin gel (TFC). J Environ Chem Eng 3:725–733

    Google Scholar 

  • Arbenz A, Averous L (2015) Chemical modification of tannins to elaborate aromatic biobased macromolecular architectures. Green Chem 17:2626–2646

    Google Scholar 

  • Asere TG, Stevens CV, Du Laing G (2019) Use of (modified) natural adsorbents for arsenic remediation: a review. Sci Total Environ 676:706–720

    Google Scholar 

  • Aspé E, Fernández K (2011) The effect of different extraction techniques on extraction yield, total phenolic, and anti-radical capacity of extracts from Pinus radiata. Bark Ind Crop Prod 34:838–844

    Google Scholar 

  • Bacelo HAM, Botelho CMS, Santos SCR (2017) Production of tannin-based adsorbents and their use for arsenic uptake from water. In: WASTES–solutions, treatments and opportunities II. CRC, Boca Raton, pp 113–118

    Google Scholar 

  • Bacelo H, Vieira BRC, Santos SCR, Boaventura RAR, Botelho CMS (2018) Recovery and valorization of tannins from a forest waste as an adsorbent for antimony uptake. J Clean Prod 198:1324–1335

    Google Scholar 

  • Beltrán-Heredia J, Palo P, Sanchéz-Martín J, Domínguez JR, González T (2012) Natural adsorbents derived from tannin extracts for pharmaceutical removal in water. Ind Eng Chem Res 52:50–57

    Google Scholar 

  • Ben Arfi R, Karoui S, Mougin K, Ghorbal A (2017) Adsorptive removal of cationic and anionic dyes from aqueous solution by utilizing almond shell as bioadsorbent Euro-Mediterr. J Environ Integ 2:20

    Google Scholar 

  • Blanchard G, Maunaye M, Martin G (1984) Removal of heavy metals from waters by means of natural zeolites. Water Res 18:1501–1507

    Google Scholar 

  • Bocalandro C, Sanhueza V, Gomez-Caravaca AM, Gonzalez-Alvarez J, Fernandez K, Roeckel M, Rodriguez-Estrada MT (2012) Comparison of the composition of Pinus radiata bark extracts obtained at bench- and pilot-scales. Ind Crop Prod 38:21–26

    Google Scholar 

  • Casentini B, Gallo M, Baldi F (2019) Arsenate and arsenite removal from contaminated water by iron oxides nanoparticles formed inside a bacterial exopolysaccharide. J Environ Chem Eng 7:102908

    Google Scholar 

  • Chupin L, Motillon C, Charrier-El Bouhtoury F, Pizzi A, Charrier B (2013) Characterisation of maritime pine (Pinus pinaster) bark tannins extracted under different conditions by spectroscopic methods, FTIR and HPLC. Ind Crop Prod 49:897–903

    Google Scholar 

  • Chupin L, Maunu SL, Reynaud S, Pizzi A, Charrier B, Charrier-El Bouhtoury F (2015) Microwave assisted extraction of maritime pine (Pinus pinaster) bark: impact of particle size and characterization. Ind Crop Prod 65:142–149

    Google Scholar 

  • Cicco N, Lattanzio V (2011) The influence of initial carbonate concentration on the Folin-Ciocalteu micro-method for the determination of phenolics with low concentration in the presence of methanol: a comparative study of real-time monitored reactions. Am J Anal Chem 2:840–848

    Google Scholar 

  • dos Santos GF, Ferrão MF, Wolf CR (2016) Development of methodology for identification the nature of the polyphenolic extracts by FTIR associated with multivariate analysis. Spectrochimica Acta Part A 153:94–101

    Google Scholar 

  • El Haouti R, Anfar Z, Et-Taleb S, Benafqir M, Lhanafi S, El Alem N (2018) Removal of heavy metals and organic pollutants by a sand rich in iron oxide. Euro-Mediterr J Environ Integr 3:17

    Google Scholar 

  • El-Moselhy MM, Ates A, Çelebi A (2017) Synthesis and characterization of hybrid iron oxide silicates for selective removal of arsenic oxyanions from contaminated water. J Colloid Interface Sci 488:335–347

    Google Scholar 

  • Fan RY, Xie F, Guan XL, Zhang QL, Luo ZR (2014) Selective adsorption and recovery of Au(III) from three kinds of acidic systems by persimmon residual based bio-sorbent: a method for gold recycling from e-wastes. Biores Technol 163:167–171

    Google Scholar 

  • Flora SJS (2015) Arsenic: chemistry, occurrence, and exposure. In: Flora SJS (ed) Handbook of arsenic toxicology. Elsevier, Amsterdam, pp 1–49

    Google Scholar 

  • Fradinho DM, Neto CP, Evtuguin D, Jorge FC, Irle MA, Gil MH, de Jesus JP (2002) Chemical characterisation of bark and of alkaline bark extracts from maritime pine grown in Portugal. Ind Crop Prod 16:23–32

    Google Scholar 

  • Freundlich HMF (1906) Over the adsorption in solution. J Phys Chem 57:385–471

    Google Scholar 

  • Ghimire KN, Inoue K, Yamaguchi H, Makino K, Miyajima T (2003) Adsorptive separation of arsenate and arsenite anions from aqueous medium by using orange waste. Water Res 37:4945–4953

    Google Scholar 

  • Hernes PJ, Hedges JI (2004) Tannin signatures of barks, needles, leaves, cones, and wood at the molecular level. Geochim Cosmochim Ac 68:1293–1307

    Google Scholar 

  • Ho YS (1995) Adsorption of heavy metals from waste streams by peat. Ph.D. Thesis, the University of Birmingham

  • Hoong YB, Paridah MT, Luqman CA, Koh MP, Loh YF (2009) Fortification of sulfited tannin from the bark of Acacia mangium with phenol-formaldehyde for use as plywood adhesive. Ind Crop Prod 30:416–421

    Google Scholar 

  • Hughes MF, Beck BD, Chen Y, Lewis AS, Thomas DJ (2011) Arsenic exposure and toxicology: a historical perspective. Toxicol Sci 123:305–337

    Google Scholar 

  • ISO 6332 (1988) Water quality—Determination of iron—Spectrometric method using 1,10-phenanthroline. ISO/TC 147/SC 2 Physical, chemical and biochemical methods

  • Karoui S, Arfi RB, Mougin K, Ghorbal A, Assadi AA, Amrane A (2020) Synthesis of novel biocomposite powder for simultaneous removal of hazardous ciprofloxacin and methylene blue: central composite design, kinetic and isotherm studies using Brouers-Sotolongo family models. J Hazard Mater 387:121675

    Google Scholar 

  • Khanbabaee K, van Ree T (2001) Tannins: classification and definition. Nat Prod Rep 18:641–649

    Google Scholar 

  • Kumari P, Sharma P, Srivastava S, Srivastava MM (2006) Biosorption studies on shelled Moringa oleifera Lamarck seed powder: removal and recovery of arsenic from aqueous system. Int J Miner Process 78:131–139

    Google Scholar 

  • Lagergren SY (1898) Zur theorie der sogenannten adsorption gelöster stoffe. K Svenska Vet Ak Handl 24:1–39

    Google Scholar 

  • Langmuir I (1918) The adsorption of gases on plane surfaces of glass, mica and platinum. J Am Chem Soc 40:1361–1403

    Google Scholar 

  • Lazar L, Talmaciu AI, Volf I, Popa VI (2016) Kinetic modeling of the ultrasound-assisted extraction of polyphenols from Picea abies bark. Ultrason Sonochem 32:191–197

    Google Scholar 

  • Luzardo FHM, Velasco FG, Correia IKS, Silva PMS, Salay LC (2017) Removal of lead ions from water using a resin of mimosa tannin and carbon nanotubes. Environ Technol Innov 7:219–228

    Google Scholar 

  • Mohan D, Pittman CU Jr (2007) Arsenic removal from water/wastewater using adsorbents—a critical review. J Hazard Mater 142:1–53

    Google Scholar 

  • Morisada S, Rin T, Ogata T, Kim YH, Nakano Y (2011) Adsorption removal of boron in aqueous solutions by amine-modified tannin gel. Water Res 45:4028–4034

    Google Scholar 

  • Mukherjee A et al (2006) Arsenic contamination in groundwater: a global perspective with emphasis on the Asian scenario. J Health Popul Nutr 24:142–163

  • Mulani K, Daniels S, Rajdeo K, Tambe S, Chavan N (2014) Tannin-aniline-formaldehyde resole resins for arsenic removal from contaminated water. Can Chem Trans 2:450

    Google Scholar 

  • Nakano Y, Takeshita K, Tsutsumi T (2001) Adsorption mechanism of hexavalent chromium by redox within condensed-tannin gel. Water Res 35:496–500

    Google Scholar 

  • Navarrete P, Pizzi A, Pasch H, Rode K, Delmotte L (2010) MALDI-TOF and 13C NMR characterization of maritime pine industrial tannin extract. Ind Crop Prod 32:105–110. https://doi.org/10.1016/j.indcrop.2010.03.010

    Article  Google Scholar 

  • Navarrete P, Pizzi A, Pasch H, Rode K, Delmotte L (2013) Characterization of two maritime pine tannins as wood adhesives. J Adhes Sci Technol 27:2462–2479. https://doi.org/10.1080/01694243.2013.787515

    Article  Google Scholar 

  • Nguyen KM, Nguyen BQ, Nguyen HT, Nguyen HTH (2019) Adsorption of arsenic and heavy metals from solutions by unmodified iron-ore sludge. Appl Sci 9:619. https://doi.org/10.3390/app9040619

    Article  Google Scholar 

  • Ogata T, Morisada S, Oinuma Y, Seida Y, Nakano Y (2011) Preparation of adsorbent for phosphate recovery from aqueous solutions based on condensed tannin gel. J Hazard Mater 192:698–703

    Google Scholar 

  • Patil-Shinde V, Mulani KB, Donde K, Chavan NN, Ponrathnam S, Tambe SS (2016) The removal of arsenite [As(III)] and arsenate [As(V)] ions from wastewater using TFA and TAFA resins: computational intelligence based reaction modeling and optimization. J Environ Chem Eng 4:4275–4286. https://doi.org/10.1016/j.jece.2016.09.030

    Article  Google Scholar 

  • Pawar RR, Kim M, Kim J-G, Hong S-M, Sawant SY, Lee SM (2018) Efficient removal of hazardous lead, cadmium, and arsenic from aqueous environment by iron oxide modified clay-activated carbon composite beads. Appl Clay Sci 162:339–350

    Google Scholar 

  • Pepino L, Brito P, Jorge FC, da Costa RP, Gil MH, Portugal A (2001) Comparison of quantification methods for the condensed tannin content of extracts of Pinus pinaster bark. In: Chiellini E, Gil H, Braunegg G, Buchert J, Gatenholm P, Van Der Zee M (eds) Biorelated polymers: sustainable polymer science and technology. Springer, Boston

    Google Scholar 

  • Ping L, Pizzi A, Guo ZD, Brosse N (2012) Condensed tannins from grape pomace: characterization by FTIR and MALDI TOF and production of environment friendly wood adhesive. Ind Crop Prod 40:13–20

    Google Scholar 

  • Pintor AMA, Vieira BRC, Santos SCR, Boaventura RAR, Botelho CMS (2018) Arsenate and arsenite adsorption onto iron-coated cork granulates. Sci Total Environ 642:1075–1089

    Google Scholar 

  • Pizzi A (2008) Tannins: major sources, properties and applications. In: Belgacem MN, Gandini A (eds) Monomers, polymers and composites from renewable resources. Elsevier, Amsterdam, pp 179–200

    Google Scholar 

  • Rahaman MS, Basu A, Islam MR (2008) The removal of As(III) and As(V) from aqueous solutions by waste materials. Biores Technol 99:2815–2823

    Google Scholar 

  • Ramos V, Bocalandro C, Riquelme S, Sanhueza V, Aspé E, Roeckel M, Fernández K (2013) Effect of the bench scale extraction conditions on Pinus radiata bark extract yield, antioxidant properties and composition. Maderas Cienc Tecnol 15:31–44

    Google Scholar 

  • Ranjan D, Talat M, Hasan SH (2009) Biosorption of arsenic from aqueous solution using agricultural residue ‘rice polish’. J Hazard Mater 166:1050–1059

    Google Scholar 

  • Ricci A, Olejar KJ, Parpinello GP, Kilmartin PA, Versari A (2015) Application of Fourier transform infrared (FTIR) spectroscopy in the characterization of tannins. Appl Spectrosc Rev 50:407–442

    Google Scholar 

  • Rivera-Utrilla J, Bautista-Toledo I, Ferro-Garcia MA, Moreno-Castilla C (2001) Activated carbon surface modifications by adsorption of bacteria and their effect on aqueous lead adsorption. J Chem Technol Biot 76:1209–1215

    Google Scholar 

  • Rodríguez-Lado L, Sun G, Berg M, Zhang Q, Xue H, Zheng Q (2013) Groundwater arsenic contamination throughout China. Science 341:866–872

    Google Scholar 

  • Sanchéz-Martín J, Beltrán-Heredia J, Gibello-Pérez P (2011) Adsorbent biopolymers from tannin extracts for water treatment. Chem Eng J 168:1241–1247

    Google Scholar 

  • Sanchez-Sanchez A, Izquierdo MT, Mathieu S, González-Álvarez J, Celzard A, Fierro V (2017) Outstanding electrochemical performance of highly N- and O-doped carbons derived from pine tannin. Green Chem 19:2653–2665

    Google Scholar 

  • Santos SCR, Bacelo HAM, Boaventura RAR (2019) Tannin-adsorbents for water decontamination and for the recovery of critical metals: current state and future perspectives. Biotechnol J 14(12):1900060

    Google Scholar 

  • Seabra IJ, Chim RB, Salgueiro P, Braga MEM, de Sousa HC (2018) Influence of solvent additives on the aqueous extraction of tannins from pine bark: potential extracts for leather tanning. J Chem Technol Biotechnol 93:1169–1182

    Google Scholar 

  • Shafique U, Ijaz A, Salman M, Uz Zaman W, Jamil N, Rehman R, Javaid A (2012) Removal of arsenic from water using pine leaves. J Taiwan Inst Chem Eng 43:256–263

    Google Scholar 

  • Singleton VL, Rossi JA (1965) Colorimetry of total phenolics with phosphomolybdic-phosphotungstic acid reagents. Am J Enol Vitic 16:144–158

    Google Scholar 

  • Te B, Wichitsathian B, Yossapol C, Wonglertarak W (2018) Development of low-cost iron mixed porous pellet adsorbent by mixture design approach and its application for arsenate and arsenite adsorption from water. Adsorpt Sci Technol 36:372–392

    Google Scholar 

  • Thomas DJ, Styblo M, Lin S (2001) The cellular metabolism and systemic toxicity of arsenic. Toxicol Appl Pharmacol 176:127–144

    Google Scholar 

  • Ungureanu G, Santos S, Boaventura R, Botelho C (2015a) Arsenic and antimony in water and wastewater: overview of removal techniques with special reference to latest advances in adsorption. J Environ Manage 152:326–342

    Google Scholar 

  • Ungureanu G, Santos S, Boaventura R, Botelho C (2015b) Biosorption of Antimony by brown algae S. muticum and A. nodosum. Environ Eng Manage J 14:455–463

    Google Scholar 

  • Vázquez G, González-Alvarez J, Freire S, López-Suevos F, Antorrena G (2001) Characteristics of Pinus pinaster bark extracts obtained under various extraction conditions. Holz Roh Werkst 59:451–456

    Google Scholar 

  • Vieira MC, Lelis RCC, da Silva BC, Oliveira GDL (2011) Tannin extraction from the bark of Pinus oocarpa var. oocarpa with sodium carbonate and sodium bisulfite. Floresta e Ambiente 18:1–8

    Google Scholar 

  • Vieira BRC, Pintor AMA, Boaventura RAR, Botelho CMS, Santos SCR (2017) Arsenic removal from water using iron-coated seaweeds. J Environ Manage 192:224–233

    Google Scholar 

  • Viswanathan T, Gunawan G, Bourdo S, Saini V, Moran J, Pack L, Owen S (2011) Evaluation of a renewable resource-based carbon-iron oxide nanocomposite for removal of arsenic from contaminated water. J Macromol Sci Part A 48:348–354

    Google Scholar 

  • Xie ZM, Huang CY (1998) Control of arsenic toxicity in rice plants grown on an arsenic-polluted paddy soil. Commun Soil Sci Plant Anal 29:2471–2477

    Google Scholar 

Download references

Acknowledgements

This work was financially supported by: Base Funding—UIDB/50020/2020 of the Associate Laboratory LSRE-LCM—funded by national funds through FCT/MCTES (PIDDAC). S.Santos acknowledges postdoctoral scholarship (SFRH/BPD/117387/2016), awarded by the Portuguese Science and Technology Foundation (FCT) and financed by National Funds and by the European Social Fund (ESF) through the Human Capital Operational Programme (POCH). H. Bacelo acknowledges PhD scholarship (PD/BD/135062/2017) funded by FCT.

The authors would also like to acknowledge Carla Ferreira and Liliana Pereira for their support of this work.

Author information

Authors and Affiliations

  1. Laboratory of Separation and Reaction Engineering–Laboratory of Catalysis and Materials (LSRE-LCM), Chemical Engineering Department, Faculdade de Engenharia da Universidade do Porto, Rua Dr. Roberto Frias, 4200-465, Porto, Portugal

    Hugo Bacelo, Sílvia C. R. Santos & Cidália M. S. Botelho

Authors
  1. Hugo Bacelo
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Sílvia C. R. Santos
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Cidália M. S. Botelho
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Sílvia C. R. Santos.

Ethics declarations

Conflict of interest

On behalf of all authors, the corresponding author states that there is no conflict of interest.

Additional information

Communicated by Mohamed Ksibi, Co-Editor in Chief.

This paper was selected from the 2nd Euro-Mediterranean Conference for Environmental Integration (EMCEI), Tunisia 2019.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Bacelo, H., Santos, S.C.R. & Botelho, C.M.S. Removal of arsenic from water by an iron-loaded resin prepared from Pinus pinaster bark tannins. Euro-Mediterr J Environ Integr 5, 47 (2020). https://doi.org/10.1007/s41207-020-00190-y

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1007/s41207-020-00190-y

Keywords

Search

Navigation