Abstract
This work investigated the feasibility of membrane filtrations such as reverse osmosis (RO) in treating whitewater from a pulp and paper mill due to thermo-mechanical pulping. The effects of pH and removal mechanisms of silicon by the membranes during treatment were discussed. Their individual performance in removing target compound was critically evaluated and compared to those of previous studies. It is found that membrane treatment could remove SiO2 from the wastewater samples. With 200 mg/L of initial concentration at pH 11 and 10 bar of pressure, 80% and 85% of silicon could be removed when applying ultrafiltration (UF) or nanofiltration (NF) membrane for 12 h. RO achieved an almost complete removal of target pollutant at 10 bar under identical conditions. Treated effluents, resulting from the membrane filtration, could comply with the maximum effluent limit of lower than 50 mg/L imposed by local legislation. Hence, further treatments are unnecessary.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Ashrafi O, Yerushalmi L, Haghighat F (2015) Wastewater treatment in the pulp-and-paper industry: a review of treatment processes and the associated greenhouse gas emission. J Environ Manage 158:146–157. https://doi.org/10.1016/j.jenvman.2015.05.010
Babel S, Kurniawan TA (2003) Low-cost adsorbents for heavy metal uptake from contaminated water: a review. J Hazard Mater B97:219–243. https://doi.org/10.1016/S0304-3894(02)00263-7
Babel S, Kurniawan TA (2004) Cr(VI) removal from synthetic wastewater using coconut shell charcoal and commercial activated carbon modified with oxidizing agents and/or chitosan. Chemosphere 54:951–967. https://doi.org/10.1016/j.chemosphere.2003.10.001
Chan G, Jie C, Kurniawan TA, Fu CX, Jiang H, Je Y (2007) Removal of non-biodegradable compounds from stabilized leachate using VSEPRO membrane filtration. Desalination 202:310–317. https://doi.org/10.1016/j.desal.2005.12.069
Dahl O (1999) Evaporation of acidic effluent from kraft pulp bleaching, reuse of the condensate and further processing of the concentrate. Oulu University, Oulu
Dahlman O, Mörck R, (1993) Chemical composition of the organic material in modern bleached kraft mill effluents. In: Södergren A (Ed): Bleached pulp mill effluents. Composition, fate and effects in Baltic Sea: environmental/cellulose II. Swedish environmental protection agency, Berlings
Davis CC, Chen HW, Edwards M (2002) Modeling silica sorption to iron hydroxide. Environ Sci Technol 36:582–587. https://doi.org/10.1021/es010996t
Den W, Huang CP (2005) Electro-coagulation for removal of silica nanoparticles from chemical-mechanical-planarization wastewater. Coll Surf A Physicochem Eng Aspects 254:81–89. https://doi.org/10.1016/j.colsurfa.2004.11.026
Den W, Huang C, Ke HC (2006) Mechanistic study on the continuous flow electro-coagulation of silica nanoparticles from polishing wastewater. Ind Eng Chem Res 45:3644–3651. https://doi.org/10.1021/ie0514410
Eskelinen K, Särkkä H, Kurniawan TA, Sillanpää M (2010) Removal of recalcitrant contaminants from bleaching effluents in pulp and paper mills using ultrasonic irradiation and fenton-like oxidation, electrochemical treatment, and/or chemical precipitation: a comparative study. Desalination 255:179–187. https://doi.org/10.1016/j.desal.2009.12.024
Fu D, Huang Y, Zhang X, Kurniawan TA, Ouyang T (2017) Uncovering potentials of integrated TiO2(B) nanosheets and H2O2 for removal of tetracycline from aqueous solution. J Mol Liquids 248:112–130. https://doi.org/10.1016/j.molliq.2017.10.020
Fu D, Kurniawan TA, Li H, Wang H, Wang Y, Li Q (2021a) Co-oxidative removal of As(III) and tetracycline (TC) from aqueous solutions based on a heterogeneous fenton’s oxidation using Fe nanoparticles-impregnated solid digestate. Environ Pollut 290:118062. https://doi.org/10.1016/j.envpol.2021.118062
Fu D, Kurniawan TA, Lan L, Yaqiong L, Avtar R, Othman MHD (2021b) Arsenic removal from aqueous solution by FeS2. J Environ Manage 286:112246. https://doi.org/10.1016/j.jenvman.2021.112246
Gallup DL, Sugiaman F, Capuno V, Manceau A (2003) Laboratory investigation of silica removal from geothermal brines to control silica scaling and produce usable silicates. Appl Geochem 18:1597–1612. https://doi.org/10.1016/S0883-2927(03)00077-5
Han N, Zhang J, Hoang M, Gray S, Xie Z (2021) A review of process and wastewater reuse in the recycled paper industry. Environ Technol Innov 24:101860. https://doi.org/10.1016/j.eti.2021.101860
Huuha TS, Kurniawan TA, Sillanpää M (2010) Removal of silicon from pulping whitewater using integrated treatment of chemical precipitation and evaporation. Chem Eng J 158:584–592. https://doi.org/10.1016/j.cej.2010.01.058
Kurniawan TA, Lo WH (2009) Removal of refractory compounds from stabilized landfill leachate using an integrated H2O2 oxidation and granular activated carbon (GAC) adsorption treatment. Water Res 43:4079–4091. https://doi.org/10.1016/j.watres.2009.06.060
Kurniawan TA, Sillanpää M (2011) Nano-adsorbents for remediation of aquatic environment: local and practical solutions for global pollution problems. Crit Rev Environ Sci Technol 42:1233–1295. https://doi.org/10.1080/10643389.2011.556553
Kurniawan TA, Lo WH, Chan G (2006a) Physico-chemical treatments for removal of recalcitrant contaminants from landfill leachate. J Hazard Mater 129:80–100. https://doi.org/10.1016/j.jhazmat.2005.08.010
Kurniawan TA, Lo WH, Chan G (2006b) Degradation of recalcitrant compounds from stabilized landfill leachate using a combination of ozone-GAC adsorption treatment. J Hazard Mater 137:443–455. https://doi.org/10.1016/j.jhazmat.2006.02.020
Kurniawan TA, Lo WH, Chan G (2006c) Radicals-catalyzed oxidation for degradation of recalcitrant compounds from landfill leachate. Chem Eng J 125:35–57. https://doi.org/10.1016/j.cej.2006.07.006
Kurniawan TA, Chan G, Lo W, Babel S (2006d) Comparison of low-cost adsorbents for treating wastewater laden with heavy metals. Sci Total Environ 366:407–424. https://doi.org/10.1016/j.scitotenv.2005.10.001
Kurniawan TA, Chan GYS, LO WH, Babel S (2006e) Physico-chemical treatment techniques for treatment of wastewater laden with heavy metals. Chem Eng J 118:83–98. https://doi.org/10.1016/j.cej.2006.01.015
Kurniawan TA, Lo W, Repo E, Sillanpää M (2010a) Removal of 4-chlorophenol from contaminated water using coconut shell waste pretreated with chemical agents. J Chem Technol Biotechnol 85:1616–1627. https://doi.org/10.1002/jctb.2473
Kurniawan TA, Lo WH, Chan G, Sillanpaa M (2010b) Biological processes for treatment of landfill leachate. J Environ Monit 12:2032–2047. https://doi.org/10.1039/c0em00076k
Kurniawan TA, Lo WH, Sillanpää M (2011) Treatment of contaminated wastewater laden with 4-chlorophenol using coconut shell waste-based activated carbon modified with different chemical agents. Sep Sci Technol 46:460–472. https://doi.org/10.1080/01496395.2010.512030
Kurniawan TA, Singh D, Xue W, Avtar R, Othman MHD, Hwang GH, Setiadi T, Albadarin AB, Shirazian S (2021a) Resource recovery toward sustainability through nutrient removal from landfill leachate. J Environ Manage 287:112265. https://doi.org/10.1016/j.jenvman.2021.112265
Kurniawan TA, Singh D, Avtar R, Othman MHD, Hwang GH, Albadarin AB, Rezakazemi M, Setiadi T, Shirazian S (2021b) Resource recovery from landfill leachate: an experimental investigation and perspectives. Chemosphere 274:129986. https://doi.org/10.1016/j.chemosphere
Kurniawan TA, Liang X, Singh D, Othman MHD, Goh HH, Gikas P, Kern AO, Kusworo TD, Shoqeir JA (2022a) Harnessing landfill gas for electricity: a strategy to mitigate greenhouse gas (GHG) emissions in Jakarta (Indonesia). J Environ Manage 301:113882. https://doi.org/10.1016/j.jenvman.2021.113882
Kurniawan TA, Othman MHD, Singh D, Avtar R, Hwang GH, Setiadi T, Lo WH (2022b) Technological solutions for long-term management of partially used nuclear fuel: a critical review. Ann Nucl Energy 166C:108736. https://doi.org/10.1016/j.anucene.2021.108736
Kurniawan TA, Liang X, O’Callaghan E, Goh HH, Othman MHD, Avtar R, Kusworo TD (2022c) Transformation of solid waste management in China: moving towards sustainability through digitalization-based circular economy. Sustainability 14:2374. https://doi.org/10.3390/su14042374
Lacorte S, Latorre A, Barcelo D, Rigol A, Malmqvist A, Welander T (2003) Organic compounds in paper-mill process waters and effluents. Trends Anal Chem 22:725–737. https://doi.org/10.1016/S0165-9936(03)01009-4
Namasivayam C, Prathap K (2007) Adsorptive removal of silica onto ‘waste’ Fe(III)/Cr(III) hydroxide: kinetics and isotherms. Coll Surf A Physicochem Eng Aspects 295:55–60. https://doi.org/10.1016/j.colsurfa.2006.08.030
Peters TA (1998) Purification of landfill leachate with reverse osmosis and nanofiltration. Desalination 119:289–293. https://doi.org/10.1016/S0011-9164(98)00171-4
Pokhrel D, Viraraghavan T (2004) Treatment of pulp and paper mill wastewater—A review. Sci Total Environ 333:37–58. https://doi.org/10.1016/j.scitotenv.2004.05.017
Premakumara DGJ, Canete ALML, Nagaishi M, Kurniawan TA (2014) Policy implementation of the Republic Act (RA) No. 9003 in the Philippines on MSW management: a case study of Cebu City. Waste Manage 34:971–979. https://doi.org/10.1016/j.wasman.2013.10.040
Repo E, Kurniawan TA, Warchol J, Sillanpaa M (2009) Removal of Co(II) and Ni(II) ions from contaminated water using silica gel functionalized with EDTA and/or DTPA as chelating agents. J Hazard Mater 171:1071–1080. https://doi.org/10.1016/j.jhazmat.2009.06.111
Sheikholeslami R, Bright J (2002) Silica and metal removal by pretreatment to prevent fouling of reverse osmosis membrane. Desalination 143:255–267. https://doi.org/10.1016/S0011-9164(02)00264-3
Sheikholeslami R, Zhou S (2000) Performance of RO membranes in silica bearing waters. Desalination 132:337–344. https://doi.org/10.1016/S0011-9164(00)00169-7
Sillanpaa M, Kurniawan TA, Lo W (2011) Degradation of chelating agents in aqueous solution using advanced oxidation process (AOP). Chemosphere 83:1443–1460. https://doi.org/10.1016/j.chemosphere
Standard Methods for the Examination of Water and Wastewater 24th (2018) American Public Health Association, Washington (US)
Tenno R, Paulapuro H (1999) Removal of dissolved organic compounds from paper machine whitewater by membrane bioreactors: a comparative analysis. Contr Eng Practice 7:1085–1099. https://doi.org/10.1016/S0967-0661(99)00079-9
Ueda A, Kato K, Mogi K, Mroczek E, Thain IA (2003) Silica removal from Mokai (New Zealand) geothermal brine by treatment with lime and a cationic precipitant. Geothermics 32:47–61. https://doi.org/10.1016/S0375-6505(02)00050-0
Vilve M, Vilhunen S, Vepsäläinen M, Kurniawan TA, Lehtonen N, Isomäki H, Sillanpää M (2010) Degradation of 1,2-dichloroethane from contaminated water laden with ion-exchange resin using Fenton’s oxidation. Environ Sci Poll Res 17:875–884. https://doi.org/10.1007/s11356-009-0291-5
Wen R, Deng S, Zhang Y (2005) The removal of silicon and boron from ultrapure water by electrodeionization. Desalination 181:153–159. https://doi.org/10.1016/j.desal.2005.02.018
Xue W, He Y, Yumunthama S, Udomkittayachai N, Hu Y, Tabucanon AS, Zhang X, Kurniawan TA (2021) Effects of membrane cleaning and operating conditions on performance of an osmotic microbial fuel cell. Chemosphere 285:131549. https://doi.org/10.1016/j.chemosphere.2021.131549
Zeng Y, Yang C, Pu W, Zhang X (2007) Removal of silica from heavy oil wastewater to be reused in a boiler by combining magnesium and zinc compounds with coagulation. Desalination 216:147–159. https://doi.org/10.1016/j.desal.2007.01.005
Zhu M, Kurniawan TA, Yanping Y, Othman MHD, Avtar R (2020) 2D Graphene oxide (GO) doped p-n type BiOI/Bi2WO6 as a novel composite for photodegradation of bisphenol A (BPA) in aqueous solutions under UV Vis irradiation. Mater Sci Eng C 108:110420. https://doi.org/10.1016/j.msec.2019.110420
Zhu M, Kurniawan TA, Avtar R, Othman MHD, Ouyang T, Yujia H, Xueting Z, Setiadi T, Iswanto I (2021a) Applicability of TiO2(B) nanosheets@hydrochar composites for adsorption of tetracycline from contaminated water. J Hazard Mater 405:123999. https://doi.org/10.1016/j.jhazmat.2020.123999
Zhu M, Kurniawan TA, Yanping Y, Othman MHD, AvtarR, Hwang GH (2021b) Fabrication, characterization, and application of ternary magnetic recyclable Bi2WO6/BiOI@Fe3O4 composite for photodegradation of tetracycline in aqueous solution. J Environ Manage 270:110839. https://doi.org/10.1016/j.jenvman.2020.110839
Acknowledgements
Support from the Universiti Teknologi Malaysia via the Research Grant No. Q.J130000.21A6.00P14 is gratefully acknowledged.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Kurniawan, T.A., Othman, M.H.D., Adam, M.R. et al. Treatment of whitewater from pulp and paper industry using membrane filtrations. Chem. Pap. 76, 5001–5010 (2022). https://doi.org/10.1007/s11696-022-02226-9
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11696-022-02226-9