Abstract
The aims of this study were the preparation, characterization, and in vitro antibacterial activity evaluation of forsterite (FS, Mg2SiO4) nanopowder obtained by two major methods, namely sol-gel (FSsg) and co-precipitation (FSpp). The main aim was to determine the influence of preparation methodologies on physical properties and in vitro antibacterial activity of obtained forsterite nanopowder. To assess the best working temperature for the preparation of FSsg and FSpp, the synthesis and thermal treatment conditions were optimized on the basis of thermal gravimetric (TG) and differential scanning calorimetric (DSC) analysis performed on the dried gel and dried co-precipitated solid, respectively. The FSsg and FSpp powders were characterized by X-ray powder diffraction (XRD), indicating a high purity for both FSsg and FSpp powders. The morphology of FSsg and FSpp nanopowders was explored by scanning electron microscopy (SEM) coupled with energy dispersive X-ray spectroscopy (EDX) and atomic force microscopy (AFM). In vitro antibacterial activity was investigated using a targeted pathogen, namely Staphylococcus aureus (S. aureus) ATCC 6538 P as tested strain by broth dilution technique and inoculations on nutrient agar to highlight the bactericidal inhibitory effect. FSsg nanopowder has no inhibitory capacity, while FSpp produced inhibition, the effect being bactericidal at a concentration of 10 mg/mL. The superior bactericidal activity of FSpp against FSsg is due to variation in the own surface properties, such as specific surface area (SSA) and nano-regime particle size. The FSpp nanoparticles, NPs, obtained by co-precipitation method are reported for the first time as a novel bactericidal nanomaterial against S. aureus.
Similar content being viewed by others
References
Anastasiou AD, Nerantzaki M, Gounari E, Duggal MS, Giannoudis PV, Jha A, Bikiaris D (2019) Antibacterial properties and regenerative potential of Sr2+ and Ce3+ doped fluorapatites; a potential solution for periimplantitis. Sci Rep 9:14469-14480. https://doi.org/10.1038/s41598-019-50916-44
Anwar A, Akbar S, Sadiqa A, Kazmi M (2016) Novel continuous flow synthesis, characterization and antibacterial studies of nanoscale zinc substituted hydroxyapatite bioceramics. Inorganica Chim Acta 453:16–22. https://doi.org/10.1016/j.ica.2016.07.041
Avram A, Gorea M, Rapuntean S, Mocanu A, Paltinean GA, Varhely C Jr, Petean I, Horovitz O, Tomoaia-Cotisel M (2020) In-vitro antibacterial activity of novel nanostructuread composites based on forsterite and silver nanoparticles. Rev Chim (Bucharest) 71(1):13–21. https://doi.org/10.37358/RC.20.1.7805
Batista AHM, Moreira ACD, de Carvalho RM, Sales GWP, Nogueira PCN, Grangeiro TB, Medeiros SC, Silveira ER, Nogueira NAP (2017) Antimicrobial effects of violacein against Planktonic cells and biofilms of Staphylococcus aureus. Molecules 22:1543. https://doi.org/10.3390/molecules22101534
Brantley SL, Mellott NP (2000) Surface area and porosity of primary silicate minerals. Am Mineral 85(11-12):1767–1783. https://doi.org/10.2138/am-2000-11-1220
Bungau S, Tit DM, Behl T, Aleya L, Zaha DC (2021) Aspects of excessive antibiotic consumption and environmental influences correlated with the occurrence of resistance to antimicrobial agents. Curr Opin Environ Sci Health 19:100224. https://doi.org/10.1016/j.coesh.2020.10.012
Choudhary R, Manohar P, Vecstaudza J, Yanez-Gascon MJ, Perez Sanchez H, Nachimuthu R, Locs J, Swamiappan S (2017) Preparation of nanocrystalline forsterite by combustion of different fuels and their comparative in-vitro bioactivity, dissolution behaviour and antibacterial studies. Mater Sci Eng C 77:811–822. https://doi.org/10.1016/j.msec.2017.03.308
Choudhary R, Chatterjee A, Venkatraman SK, Koppala S, Abraham J, Swamiappan S (2018) Antibacterial forsterite (Mg2SiO4) scaffold: a promising bioceramic for load bearing applications. Bioact Mater 3(3):218–224. https://doi.org/10.1016/j.bioactmat.2018.03.003
Choudhary R, Venkatraman SK, Bulygina I, Chatterjee A, Abraham J, Senatov F, Kaloshkin S, Ilyasov A, Abakumov M, Knyazeva M, Kukui D, Walther F, Swamiappan S (2020) Impact of forsterite addition on mechanical and biological properties of composites. J Asian Ceram Soc 8(4):1051–1065. https://doi.org/10.1080/21870764.2020.1807695
Chung R-J, Hsieh M-F, Huang C-W, Perng L-H, Wen H-W, Chin T-S (2006) Antimicrobial effects and human gingival biocompatibility of hydroxyapatite sol–gel coatings. Chin J Biomed Mater Res B Appl Biomater 76:169–178. https://doi.org/10.1002/jbm.b.303655
Corami A, Mignardi S, Ferrini V (2008) Cadmium removal from single- and multi-metal (Cd+Pb+Zn+Cu) solutions by sorption on hydroxyapatite. J Colloid Interface Sci 317:402–408. https://doi.org/10.1016/j.jcis.2007.09.075
Costescu A, Andronescu E, Vasile BS, Trusca R, Le Coustumer P, Barna ES, Iconaru SL, Montelica-Heino M, Ciobanu CS (2014) Synthesis and characterization of dextran coated hydroxyapatite for environmental applications. U Politeh Buch Sci Bull Ser B 76(4):71–80
Cutinelli C, Galdiero F (1967) Ion-binding properties of the cell wall of Staphylococcus aureus. J Bacteriol 93(6):2022–2023. https://doi.org/10.1128/jb.93.6.2022-2023.1967
David MZ, Daum RS (2010) Community-associated methicillin-resistant Staphylococcus aureus: epidemiology and clinical consequences of an emerging epidemic. Clin Microbiol Rev 23(3):616–687. https://doi.org/10.1128/cmr.00081-09
Demishtein K, Reifen R, Shemesh M (2019) Antimicrobial properties of magnesium open opportunities to develop healthier food. Nutrients 11(10):2363-2368. https://doi.org/10.3390/nu11102363
Douy A (2002) Aqueous syntheses of forsterite (Mg2SiO4) and enstatite (MgSiO3). J Solgel Sci Technol 24:221–228
Elwakeel KZ, El-Liethy MA, Ahmed MS, Ezzat SM, Kamel MM (2018) Facile synthesis of magnetic disinfectant immobilized with silver ions for water pathogenic microorganism’s deactivation. Environ Sci Pollut Res 25:22797–22809. https://doi.org/10.1007/s11356-018-2071-6
Emelyanenko AM, Domantovsky AG, Kaminsky VV, Pytskii IS, Emelyanenko KA, Boinovich LB (2021) The mechanisms of antibacterial activity of magnesium alloys with extreme wettability. Materials 14:5451. https://doi.org/10.3390/ma14185454
Esteves GM, Esteves J, Resende M, Mendes L, Azevedo AS (2022) Antimicrobial and antibiofilm coating of dental implants—past and new perspectives. Antibiotics 11:235. https://doi.org/10.3390/antibiotics11020235
Fernane F, Boudia B, Saouli H (2013) Interactions between calcium phosphate and heavy metal ions in aqueous solution. MATEC Web of Conferences 5:1–5. https://doi.org/10.1051/matecconf/20130504034
Furtos G, Naghiu MA, Declercq H, Gorea M, Prejmerean C, Pana O, Tomoaia-Cotisel M (2016) Nano forsterite biocomposites for medical applications: mechanical properties and bioactivity. Biomed Mater Res Part B Appl Biomater 104B(7):1290–1301. https://doi.org/10.1002/jbm.b.33396
Gabutti G, de Donno A, Bagordo F, Montagna MT (2000) Comparative survival of faecal and human contaminants and use of Staphylococcus aureus as an effective indicator of human pollution. Mar Pollut Bull 40(8):697–700. https://doi.org/10.1016/S0025-326X(00)00007-2
Garbo C, Locs J, D’Este M, Demazeau G, Mocanu A, Roman C, Horovitz O, Tomoaia-Cotisel M (2020) Advanced Mg, Zn, Sr, Si multi-substituted hydroxyapatites for bone regeneration. Int J Nanomed 15:1037–1058. https://doi.org/10.2147/IJN.S226630
Gorea M, Naghiu M-A, Avram A, Petean I, Mocanu A, Tomoaia-Cotisel M (2020) Novel porous forsterite ceramics biocompatibility and bioactivity evaluation. Rev Chim 71(2):343–351. https://doi.org/10.37358/RC.20.2.7935
Gupta N, Kushawaha AK, Chattopadhyaya MC (2011) Adsorption of cobalt (II) from aqueous solution onto hydroxyapatite/zeolite composite. Adv Mat Lett 2(4):309–312. https://doi.org/10.5185/amlett.indias.201
Hammad ABA, El Hanwary AM, Hemdan BA, Abia ALK (2020) Nanoceramics and novel functionalized silicate-based magnetic nanocomposites as substitutional disinfectants for water and wastewater purification. Environ Sci Pollut Res 27:26668–26680
Hieu DTM, Tran PTT, Ton AK, Le MV (2016) A novel method for the fabrication of granular hydroxyapatite-bentonite composite adsorbents for the removal of Pb2+ from an aqueous solution. J Environ Sci Eng B 5:371–378. https://doi.org/10.17265/2162-5263/2016.07.008
Horovitz O, Tomoaia G, Mocanu A, Yupsanis T, Tomoaia-Cotisel M (2007) Protein binding to gold auto-assembled films. Gold Bull 40(4):295–304. https://doi.org/10.1007/BF03215603
Ince OK, Ince M, Kraaslan NM, Yonten V (2016) Optimization of cadmium removal from water by hydroxyapatite using experimental design methodology. Anal Lett 49(15):2513–2524. https://doi.org/10.1080/00032719.2016.1151022
Li Q, Mahendra S, Lyon DY, Brunet L, Liga MV, Li D, Alvarez PJJ (2008) Antimicrobial nanomaterials for water disinfection and microbial control: potential applications and implications. Water Res 42:4591–4602. https://doi.org/10.1016/j.watres.2008.08.015
Liang M, Ge X, Xua H, Ma K, Zhang W, Zan Y, Efferth T, Xue Z, Hua X (2022) Phytochemicals with activity against methicillin-resistant Staphylococcus aureus. Phytomedicine 100:154073. https://doi.org/10.1016/j.phymed.2022.154073
Lloyd FE, Bailey DK (1975) Light element metasomatism of the continental mantle: the evidence and the consequences. In: Ahrens LH, Dawson JB, Duncan AR, Erlank AJ (eds) Physics and chemistry of the earth, vol. 9, Pergamon Press, Oxford · New York · Toronto · Sydney · Paris · Frankfurt, pp 412.
Mathur L, Hossain SKS, Majhi MR, Roy PK (2018) Synthesis of nano-crystalline forsterite (Mg2SiO4) powder from biomass rice husk silica by solid-state route. Bol Soc Esp Ceram V 57:112–118
Menz BD, Charani E, Gordon DL, Leather AJM, Moonesinghe SR, Phillips CJ (2021) Surgical antibiotic prophylaxis in an era of antibiotic resistance: common resistant bacteria and wider considerations for practice. Infect Drug Resist 14:5235–5252. https://doi.org/10.2147/IDR.S319780
Mocanu A, Furtos G, Rapuntean S, Horovitz O, Flore C, Garbo C, Danisteanu A, Rapuntean G, Prejmerean C, Tomoaia-Cotisel M (2014) Synthesis characterization and antimicrobial effects of composites based on multi-substituted hydroxyapatite and silver nanoparticles. Appl Surf Sci 298:225–235. https://doi.org/10.1016/j.apsusc.2014.01.166
Naghiu MA, Gorea M, Mutch E, Kristaly F, Tomoaia-Cotisel M (2013) Forsterite nanopowder: structural characterization and biocompatibility evaluation. J Mater Sci Technol. 29(7):628–632. https://doi.org/10.1016/j.jmst.2013.04.007
Narwade VN, Mahabole MP, Bogle KA, Khaimar RS (2014) Waste water treatment by nanoceramics: removal of lead particles. Int J Eng Sci Innov Technol 3(3):324–328
Nehru M, Sumathi S (2013) Removal of cadmium (II) and nickel (II) ions by copper substituted hydroxyapatite. Int J Appl Eng Res 8(19):2179–2181
Oltean-Dan D, Dogaru G-B, Tomoaia-Cotisel M, Apostu D, Mester A, Benea H-R-C, Paiusan M-G, Jianu E-M, Mocanu A, Balint R, Popa C-O, Berce C, Bodizs G-I, Toader A-M, Tomoaia G (2019) Enhancement of bone consolidation using highfrequency pulsed electromagnetic short-waves and titanium implants coated with biomimetic composite embedded into PLA matrix: in vivo evaluation. Int J Nanomed 14:5799–5816. https://doi.org/10.2147/IJN.S205880
Oltean-Dan D, Dogaru G-B, Jianu E-M, Riga S, Tomoaia-Cotisel M, Mocanu A, Barbu-Tudoran L, Tomoaia G (2021) Biomimetic composite coatings for activation of titanium implant surfaces: methodological approach and in vivo enhanced osseointegration. Micromachines 12:1325. https://doi.org/10.3390/mi12111352
Perrault DP, Sharma A, Kim JF, Gurtner GC, Wan DC (2022) Surgical applications of materials engineered with antimicrobial properties. Bioengineering 9:138. https://doi.org/10.3390/bioengineering9040138
Ramaite K, Ekwanzala MD, Dewar JB, Momba MNB (2021) Human-associated methicillin-resistant Staphylococcus aureus clonal complex 80 isolated from cattle and aquatic environments. Antibiotics 10:1038. https://doi.org/10.3390/antibiotics10091038
Rand RR, Sengupta S (1972) Cardiolipin forms hexagonal structures with divalent cations. Biochim Biophys Acta 255:484–492
Sanosh KP, Balakhrishnan A, Francis L, Kim TN (2010) Sol–gel synthesis of forsterite nanopowders with narrow particle size distribution. J Alloy Compd 495:113–115
Saqaei M, Fathi M, Edris H, Mortazavi V, Hosseini N (2016) Effects of adding forsterite bioceramic on in vitro activity and antibacterial properties of bioactive glass-forsterite nanocomposite powders. Adv Powder Technol 27:1922–1932. https://doi.org/10.1016/j.apt.2016.06.023
Sennato S, Bordi F, Cametti C, Coluzza C, Desideri A, Rufini S (2005) Evidence of domain formation in cardiolipin-glycerophospholipid mixed monolayers. A thermodynamic and AFM study. J Phys Chem 109(33):15950–15957
Short SA, White DC (1971) Metabolism of phosphatidylglycerol, lysylphosphatidylglycerol, and cardiolipin of Staphylococcus aureus. J Bacteriol 108(1):219–226
Som A, Yang L, Wong GCL, Tew GN (2009) Divalent metal ion triggered activity of a synthetic antimicrobial in cardiolipin membranes. J Am Chem Soc 131(42):15102–15103
Subramani S, Perdreau-Dahl, Morth JP (2016) The magnesium transporter A is activated by cardiolipin and is highly sensitive to free magnesium in vitro. eLife 5:e11407. https://doi.org/10.7554/eLife.11407
Tsai M, Ohniwa RL, Kato Y, Takeshita SL, Ohta T, Saito S, Hayashi H, Morikawa K (2011) Staphylococcus aureus requires cardiolipin for survival under conditions of high salinity. Microbiol 11:13 (12 pages).
Varela AR, Manaia CM (2013) Human health implications of clinically relevant bacteria in wastewater habitats. Environ Sci Pollut Res 20:3550–3569. https://doi.org/10.1007/s11356-013-1594-0
Venkatraman SK, Choudhary R, Vijayakumar N, Krishnamurithy G, Raghavendran HRB, Murali MR, Kamarul T, Suresh A, Abraham J, Swamiappan S (2022) Investigation on bioactivity, mechanical stability, bactericidal activity and in-vitro biocompatibility of magnesium silicates for bone tissue engineering applications. J Mater Res 37:608–621. https://doi.org/10.1557/s43578-021-00450-9
Wang Q, Zhang Y, LiQ CL, Liu H, Ding M, Dong H, Mou Y (2022) Therapeutic applications of antimicrobial silver-based biomaterials in dentistry. Int J Nanomed 17:443–462. https://doi.org/10.2147/IJN.S349238
Wu Z, Chan B, Low J, Chu JJH, Hey HWD, Tay A (2022) Microbial resistance to nanotechnologies: an important but understudied consideration using antimicrobial nanotechnologies in orthopaedic implants. Bioact Mater 16:249–270. https://doi.org/10.1016/j.bioactmat.2022.02.014
Xie Y, Yang L (2016) Calcium and magnesium ions are membrane-active against stationary-phase Staphylococcus aureus with high specificity. Sci Rep 6:20628
Zaha DC, Bungau S, Uivarosan D, Tit DM, Maghiar TA, Maghiar O, Pantis C, Fratila O, Rus M, Vesa CM (2020) Antibiotic consumption and microbiological epidemiology in surgery departments: results from a single study center. Antibiotics 9:81. https://doi.org/10.3390/antibiotics9020081
Zamani S, Salahi E, Mobasherpour I (2013) Removal of nickel from aqueous solution by nano hydroxyapatite originated from Persian Gulf corals. Can Chem Trans 1(3): 173-190. https://doi.org/10.13179/canchemtrans.2013.01.03.0033
Zampiva RYS, Acauan LH, dos Santos LM, Ribeiro de Castro RH, Kopp Alves A, Perez Bergmann C (2017) Nanoscale synthesis of single phase forsterite by reverse strike co-precipitation and its high optical and mechanical properties. Ceram Int 43(16):16225–16231. https://doi.org/10.1016/j.ceramint.2017.08.201
Zdrenghea UV, Tomoaia G, Pop-Toader D-V, Mocanu A, Horovitz O, Tomoaia-Cotisel M (2011) Procaine effect on human erythrocyte membrane explored by atomic force microscopy. Comb Chem High Throughput Screen 14(4):237–247. https://doi.org/10.2174/138620711795222491
Zhang Y, Ni H, Chen Y (2010) Diffusion data in silicate melts. Rev Mineral Geochem 72:311–408. https://doi.org/10.2138/rmg.2010.72.8
Zhu T, Zhu M, Zhu Y (2020) Fabrication of forsterite scaffolds with photothermal-induced antibacterial activity by 3D printing and polymer-derived ceramics strategy. Ceram Int 46:13607–13614. https://doi.org/10.1016/j.ceramint.2020.02.146
Acknowledgments
Authors gratefully acknowledge the Research Centre of Excellence in Physical Chemistry, at Babes-Bolyai University of Cluj-Napoca, for DSC, AFM and synthesis facilities. Professor Dr. Maria Tomoaia-Cotisel is the Founder (2006) and the Director (2006-present) of this Research Centre. Authors gratefully thank Associate Professor Dr. Firuta Goga for thermal treatment assistance and Professor Dr. George Borodi for XRD assistance. Authors would like to express their highest gratitude to the Romanian Executive Agency for Higher Education, Research, Development and Innovation Funding, UEFISCDI, for the support of research projects no. 186 and 481.
Funding
This work was supported by grants of the Ministry of Research, Innovation and Digitization, CNCS/CCCDI-UEFISCDI, project number 186 and 481, within PNCDI III.
Author information
Authors and Affiliations
Contributions
AA participated in FS synthesis and characterization, data analysis, literature research, manuscript writing. SR performed antimicrobial testing and data analysis. MG participated in FS synthesis and morphological characterization. GhT participated in research planning and antibacterial study. AM designed the experiment and participated in the FS physical characterization and data analysis. OH participated in design of this study, data analysis, and assisted the revision of the manuscript. GhR performed antimicrobial testing and data analysis, and participated in the manuscript writing and revision. MTC conceived and designed the study, aimed antibacterial mechanism, and assisted the changes to the revised manuscript based on the comments of the reviewers. MTC is corresponding author. The authors agree to be accountable for all aspects of this study. All authors have equal contributions. The authors have read and approved the final manuscript.
Corresponding author
Ethics declarations
Competing interests
The authors declare no competing interests.
Additional information
Responsible Editor: Mohamed M. Abdel-Daim
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Avram, A., Rapuntean, S., Gorea, M. et al. In vitro antibacterial effect of forsterite nanopowder: synthesis and characterization. Environ Sci Pollut Res 29, 77097–77112 (2022). https://doi.org/10.1007/s11356-022-21280-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-022-21280-0