Abstract
Zinc oxide (ZnO) nanoparticles were synthesized by precipitation and sol-gel methods. The aim of this study was to understand how different synthetic methods can affect the photocatalytic activity of ZnO nanoparticles. As-synthesized ZnO nanoparticles were characterized by X-ray diffraction (XRD) and UV-Visible spectroscopic techniques. XRD patterns of ZnO powders synthesized by precipitation and sol-gel methods revealed their hexagonal wurtzite structure with crystallite sizes of 30 and 28 nm, respectively. Their photocatalytic activities were evaluated by photocatalytic degradation of methylene blue, a common water pollutant, under UV radiation. The effects of operational parameters such as photocatalyst load and initial concentration of the dye on photocatalytic degradation of methylene blue were investigated. While the degradation of dye decreased over the studied dye concentration range of 20 to 100 mg/L, an optimum photocatalyst load of 250 mg/L was needed to achieve dye degradation as high as 81 and 92.5 % for ZnO prepared by precipitation and sol-gel methods, respectively. Assuming pseudo first-order reaction kinetics, this corresponded to rate constants of 8.4 × 10−3 and 12.4 × 10−3 min−1, respectively. Hence, sol-gel method is preferred over precipitation method in order to achieve higher photocatalytic activity of ZnO nanostructures. Photocatalytic activity is further augmented by better choice of capping ligand for colloidal stabilization, starch being more effective than polyethylene glycol (PEG).
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Abu Tariq M, Faisal M, Saquib M, Muneer M (2008) Heterogeneous photocatalytic degradation of anthraquinone and a triphenylmethane dye derivative in aqueous suspensions of semiconductor. Dyes Pigments 76:358–365
Anandan S, Vinu A, Sheeja Lovely KLP, Gokulakrishnan N, Srinivasu P, Mori T, Murugesan V, Sivamurugan V, Ariga K (2007) Photocatalytic activity of La-doped ZnO for the degradation of monocrotophos in aqueous suspension. J Mol Catal A Chem 266:149–157
Baruwati B, Kumar DK, Manorama SV (2006) Hydrothermal synthesis of highly crystalline ZnO nanoparticles: a competitive sensor for LPG and EtOH. Sensors Actuators B Chem 119:676–682
Berger LI (1997) Semiconductor materials. CRC Press, Boca Raton, FL
Bian JM, Li XM, Zhang CY, Chen LD, Yao Q (2004) Synthesis and characterization of two-layer-structured ZnO p-n homojunctions by ultrasonic spray pyrolysis. Appl Phys Lett 84(19):3783–3785
Daneshvar N, Salari D, Khataee AR (2004) Photocatalytic degradation of azo dye acid red 14 in water on ZnO as an alternative catalyst to TiO2. J Photochem Photobiol A Chemistry 162:317–322
Danion A, Disdier J, Guillard C, Jaffrezic-Renault N (2007) Malic acid photocatalytic degradation using a TiO2-coated optical fiber reactor. J Photochemistry and Photobiology A Chemistry 190:135–140
Dey T (2012) Nanotechnology for water purification, Chapters 6 and 7. Universal Publishers, Boca Raton, FL, USA ISBN: 1612336191
Franco Arias LM, Arias Duran A, Cardona D, Camps E, Gomez ME, Zambrano G (2015) Effect of annealing treatment on the photocatalytic activity of TiO2 thin films deposited by DC reactive magnetron sputtering. J Phys Conf Ser 614:012008
Getaye M, Yadav OP, Taddesse A, Jain DVS (2015) Effect on photo-catalytic activity of zinc oxide nanoparticles upon doping with silver and sulphur in degradation reaction of malachite green. J Surface Sci Technol 31:69–76
Guesh K, Yadav OP, Tadesse A (2013) Effect of Ag-N co-doping in nanosize TiO2 on photocatalytic degradation of methyl orange dye. J Surface Science and Technol 29:1–14
Hayat K, Gondal MA, Khaled MM, Ahmed S, Shemsi AM (2011) Nano ZnO synthesis by modified sol gel method and its application in heterogeneous photocatalytic removal of phenol from water. Applied Catalysis A 393:122–129
Hoffmann MR, Martin ST, Choi W, Bahnemann DW (1995) Environmental applications of semiconductor photocatalysis. Chem Rev 95:69–96
Ivetic TB, Dimitrievska MR, Fincur NL, Dacanin LR, Guth IO, Abramovic BA, Lukic-Petrovic SR (2014) Effect of annealing temperature on structural and optical properties of Mg-doped ZnO nanoparticles and their photocatalytic efficiency in alprazolam degradation. Ceram Int 40:1545–1552
Kang S-Z, Wu T, Li X, Mu J (2010) A facile gelatin-assisted preparation and photocatalytic activity of zinc oxide nanosheets. Colloids and Surfaces A: Physicochem and Eng Aspects 369:268–271
Kwon CH, Shin H, Kim JH, Choi WS, Yoon KH (2004) Degradation of methylene blue via photocatalysis of titanium dioxide. Mater Chemistry Physics 86:78–82
Meruvu H, Vangalapati M, Chippada SC, Bammidi SR (2011) Synthesis and characterization of zinc oxide nanoparticles and its antimicrobial activity against Bacillus subtilis and Escherichia coli. RASAYAN J Chem 4(1):217–222
Nibret A, Yadav OP, Diaz I, Taddesse AM (2015) Cr-N Co-doped ZnO nanoparticles: synthesis, characterization and photo-catalytic activity for degradation of thymol blue. Bull Chem Soc Ethiopia 29(2):247–258
Parida KM, Dash SS, Das DP (2006) Chemical characterization and photocatalytic activity of zinc oxide prepared by various methods. J Colloid Sci 298:787–793
Perez-Lopez OW, Farias AC, Marcilio NR, Bueno JMC (2005) The catalytic behavior of zinc oxide prepared from various precursors and by different methods. Mater Res Bull 40:2089–2099
Rauf MA, Bukallah SB, Hamadi A, Sulaiman A, Hammadi F (2007) The effect of operational parameters on the photoinduced decoloration of dyes using a hybrid catalyst V2O5/TiO2. J Chemical Engineering 129:167–172
Rodriguez-Paez JE, Caballero AC, Villegas M, Moure C, Duran P, Fernandez JF (2001) Controlled precipitation methods: formation mechanism of ZnO nanoparticles. J Eur Ceram Soc 21:925–930
Shanthi M, Kuzhalosai V (2012) Photocatalytic degradation of an azo dye, acid red 27, in aqueous solution using nano ZnO. Indian J Chem 51A:428–434
Shen W, Li Z, Wang H, Liu Y, Guo Q, Zhang Y (2008) Photocatalytic degradation for methylene blue using zinc oxide prepared by codeposition and sol–gel methods. J Hazardous Materials 152:172–175
Skorb EV, Ustinovich EA, Kulak AI, Sviridov DV (2008) Photocatalytic activity of TiO2:In2O3 nanocomposite films towards the degradation of arylmethane and azo dyes. J Photochemistry and Photobiology Chemistry 193:97–102
Soosen SM, Bose L, George KC (2009) Optical properties of ZnO nanoparticles. Academic Review 16:57–65
Welderfael T, Yadav OP, Tadesse A, Kaushal J (2013) Synthesis, characterization and photocatalytic activities of Ag-N-co-doped ZnO nanoparticles for degradation of methyl red dye. Bull Chem Soc Ethiopia 27(2):1–12
Yang J, Liu X, Yang L, Wang Y, Zhang Y, Lang J, Gao M, Feng B (2009) Effect of annealing temperature on the structure and optical properties of ZnO nanoparticles. J Alloys Compd 477:632–635
Zhang XH, Xie SY, Jiang ZY, Zhang X, Tian ZQ, Xie ZX, Huang RB, Zheng LS (2003) Rational design and fabrication of ZnO nanotubes from nanowire templates in a microwave plasma system. J Phys Chem 107:10114–10118
Zheng M, Wu J (2009) One-step synthesis of nitrogen-doped ZnO nanocrystallites and their properties. Appl Sur Sci 255:5656–5661
Acknowledgments
The authors would like to thank the Geological Survey of Ethiopia (GSE) for providing the XRD analysis facility.
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible editor: Philippe Garrigues
Rights and permissions
About this article
Cite this article
Balcha, A., Yadav, O.P. & Dey, T. Photocatalytic degradation of methylene blue dye by zinc oxide nanoparticles obtained from precipitation and sol-gel methods. Environ Sci Pollut Res 23, 25485–25493 (2016). https://doi.org/10.1007/s11356-016-7750-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-016-7750-6