Abstract
The character of transitional capillary flow is investigated using pressure-drop measurements and instantaneous velocity fields acquired by microscopic PIV in the streamwise–wall-normal plane of a 536 μm capillary over the Reynolds-number range 1,800 ≤ Re ≤ 3,400 in increments of 100. The pressure-drop measurements reveal a deviation from laminar behavior at Re = 1,900 with the differences between the measured and the predicted laminar-flow pressure drop increasing with increasing Re. These observations are consistent with the characteristics of the mean velocity profiles which begin to deviate from the parabolic laminar profile at Re = 1,900, interpreted as the onset of transition, by becoming increasingly flatter and fuller with increasing Re. A fully-turbulent state is attained at Re ≅ 3,400 where the mean velocity profile collapses onto the mean profile of fully-developed turbulent pipe flow from an existing direct numerical simulation at Re = 5,300. Examination of the instantaneous velocity fields acquired by micro-PIV in the range 1,900 ≤ Re < 3,400 reveal that transitional flows at the microscale are composed of a subset of velocity fields illustrating a purely laminar behavior and a subset of fields that capture significant departure from laminar behavior. The fraction of velocity fields displaying non-laminar behavior increases with increasing Re, consistent with past observations of a growing number of intermittent turbulent spots bounded by nominally laminar flow in macroscale pipe flow with increasing Re. Instantaneous velocity fields that are non-laminar in character consistently contain multiple spanwise vortices that appear to streamwise-align to form larger-scale interfaces that incline slightly away from the wall. The characteristics of these “trains” of vortices are reminiscent of the spatial features of hairpin-like vortices and hairpin vortex packets often observed in fully-turbulent wall-bounded flow at both the macro- and micro-scales. Finally, single-point statistics computed from the non-laminar subsets at each transitional Re, including root-mean-square velocities and the Reynolds shear stress, reveal a gradual and smooth maturation of the patches of disordered motion toward a fully-turbulent state with increasing Re.
Similar content being viewed by others
References
Abell CJ (1974) Scaling laws for pipe flow turbulence. PhD thesis, University of Melbourne
Adams TM, Abdel-Khalik SI, Jeter SM, Qureshi ZH (1998) An experimental investigation of single-phase forced convection in microchannels. Int J Heat Mass Transf 41:851–857
Adrian RJ, Christensen KT, Liu ZC (2000a) Analysis and interpretation of instantaneous turbulent velocity fields. Exp Fluids 29:275–290
Adrian RJ, Meinhart CD, Tomkins CD (2000b) Vortex organization in the outer region of the turbulent boundary layer. J Fluid Mech 422:1–54
Bake S, Meyer GW, Rist U (2002) Turbulence mechanism in Klebanoff transition: a quantitative comparison of experiment and direct numerical simulation. J Fluid Mech 459:217–243
Cui H-H, Silber-Li Z-H (2004) Flow characteristics of liquids in microtubes driven by high pressure. Phys Fluids 16:1803–1810
Darbyshire AG, Mullin T (1995) Transition to turbulence in a constant-mass–flux pipe flow. J Fluid Mech 289:83–114
Eggels JGM, Unger F, Weiss MH, Westerweel J, Adrian RJ, Friedrich R, Nieuwstadt FTM (1994) Fully developed turbulent pipe flow: a comparison between direct numerical simulation and experiment. J Fluid Mech 268:175–209
Gravesen P, Branebjerg J, Jensen OS (1993) Microfluidics—a review. J Micromech Microeng 3:168–182
Haswell SJ, Skelton V (2000) Chemical and biochemical microreactors. TrAC Trends Analyt Chem 7:389–395
Hof B, van Doorne CWH, Westerweel J, Niuewstadt FTM, Faisst H, Eckhardt B, Wedin H, Kerswell RR, Waleffe F (2004) Experimental observation of nonlinear traveling waves in turbulent pipe flow. Science 305:1594–1598
Judy J, Maynes D, Webbs BW (2002) Characterization of frictional pressure drop for liquid flows through microchannels. International J Heat Mass Transf 45:3477–3489
Kerswell KR (2005) Recent progress in understanding the transition to turbulence in a pipe. Nonlinearity 18:R17–R44
Kline SJ, Robinson SK (1989) Quasi-coherent structures in thr turbulent bounday layer. Part 1: status report on a community-wide summary of the data. Hemisphere, New York, pp 218–247
Li H, Olsen MG (2006a) Aspect ratio effects in turbulent and transitional flow in rectangular microchannels as measured with micropiv. J Fluids Eng 128:305–315
Li H, Olsen MG (2006b) Examination of large-scale structures in turbulent microchannel flow. Exp Fluids
Li H, Ewoldt R, Olsen MG (2005) Turbulent and transitional velocity measurements in a rectangular microchannel using microscopic particle image velocimetry. Exp Thermal Fluid Sci 29:435–446
Mala GM, Li D (1999) Flow characteristics of water in microtubes. International J Heat Fluid Flow 20:142–148
Meinhart CD, Adrian RJ (1995) On the existence of uniform momentum zones in a turbulent boundary layer. Phys Fluids 7(4):694–696
Meinhart CD, Wereley ST, Santiago JG (2000) PIV measurements of a microchannel flow. Exp Fluids 27:414–419
Natrajan VK, Yamaguchi E, Christensen KT (2007) Statistical and structural similarities between micro- and macro-scale wall turbulence. Microfluidics Nanofluidics 3:89–100
Olsen MG, Adrian RJ (2000) Out-of-focus effects on particle image visibility and correlation in microscopic particle image velocimetry. Exp Fluids 29:S166–S174
Peng XF, Peterson GP (1996) Convective heat transfer and flow friction for water flow in microchannel structures. Int J Heat Mass Transf 39:2599–2608
Peng XF, Peterson GP, Wang BX (1994) Frictional flow characteristics of water flowing through rectangular microchannels. Exp Heat Transf 7:249–264
Prasad AK, Adrian RJ, Landreth CC, Offutt PW (1992) Effect of resolution on the speed and accuracy of particle image velocimetry interrogation. Exp Fluids 13:105–116
Qu W, Mala GM, Li D (2000) Pressure driven water flows in trapeziodal silicon microchannels. Int J Heat Fluid Flow 43:353–364
Qu W, Mudawar I (2002) Experimental and numerical study of pressure drop and heat transfer in a single-phase micro-channel heat sink. Int J Heat Mass Transf 45:2549–2565
Reynolds O (1883) An experimental investigation of circumstances which determine whether the motion of water shall be direct or continuous, and the law of resistance in parallel channels. Philos Trans R Soc Lond 174:935–982
Rubin Y, Wygnanski IJ, Haritonidis JH (1979) Further observations on transition in a pipe. In: Proceedings of the IUTAM symposium, pp 19–26
Santiago JG, Wereley ST, Meinhart CD, Beebe DJ, Adrian RJ (1998) A particle image velocimetry system for microfluidics. Exp Fluids 25:316–319
Schröder A, Kompenhans J (2004) Investigation of a turbulent spot using multi-plane stereo particle image velocimetry. Exp Fluids 36:82–90
Sharp KV, Adrian RJ (2004) Transition from laminar to turbulent flow in liquid filled microtubes. Exp Fluids 36:741–747
Singer BA, Joslin RD (1994) Metamorphosis of a hairpin vortex into a young turbulent spot. Phys Fluids 6(11):3724–3756
Tuckerman DB, Pease RF (1981) High-performance heat sinking for VLSI. IEEE Electr Device Lett 2:126–129
Wang BX, Peng XF (1994) Experimental investigation on liquid forced-convection heat transfer through microchannels. International J Heat Mass Transf 37:73–82
White FM (1994) Fluid Mechanics. McGraw Hill, New York
Wu P, Little WA (1983) Measurements of friction factor for the flow of gases in very fine channels used for micro-miniature Joule–Thompson refrigerators. Cryogenics 23:273–277
Wu Y, Christensen KT (2006) Population trends of spanwise vortices in wall turbulence. J Fluid Mech 568:55–76
Wygnanski IJ, Champagne FH (1973) On transition in a pipe. Part 1. The origin of puffs and slugs and the flow in a turbulent slug. J Fluid Mech 59:281–335
Wygnanski IJ, Sokolov M, Friedman D (1975) On transition in a pipe. Part 2. The equilibrium puff. J Fluid Mech 69:283–304
Zagarola MV, Smits AJ (1998) Mean-flow scaling of turbulent pipe flow. J Fluid Mech 373:33–79
Zhou J, Adrian RJ, Balachandar S, Kendall TM (1999) Mechanisms for generating coherent packets of hairpin vortices in channel flow. J Fluid Mech 387:353–396
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Natrajan, V.K., Christensen, K.T. Microscopic particle image velocimetry measurements of transition to turbulence in microscale capillaries. Exp Fluids 43, 1–16 (2007). https://doi.org/10.1007/s00348-007-0301-7
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00348-007-0301-7