Abstract
Some methods for analysing N,N-dimethylformamide and its metabolites [hydroxymethyl-N-methylformamide, hydroxymethylformamide and N-acetyl-S-(N-methylcarbamoyl)cysteine] in the urine of exposed workers are described. Unchanged dimethylformamide was measured after pretreatment of urine (2 ml) with silica gel cartridges and elution with methanol. The gas chromatographic analysis using a nitrogen phosphor detector made it possible to detect N,N-dimethylformamide in urine even when workers were exposed to low concentrations of the solvent (about 1 mg/m3). N-Hydroxymethyl-N-methylformamide and N-hydroxymethylformamide were analysed as N-methylformamide and formamide respectively after direct injection of urine into the gas chromatograph. The injection port temperature played an important role in the gas chromatographic determination of these products. Reliable results were obtained when direct or split injections were performed at 250°C. The splitless injection gave the same reliable results at 150°C. In urine samples from occupationally non-exposed persons, N-methylformamide could not be detected. In contrast, formamide (or its precursor, hydroxymethylformamide) was present in every urine sample. Our results in respect of 19 urine samples analysed with the injection port of the gas chromatograph at 250°C gave a mean of 8.6 mg/l of formamide. N-Acetyl-S-(N-methylcar-bamoyl)cysteine was determined using a modified method for analysing organic acid in urine samples. The metabolite was extracted with ethyl ether in an acid environment, treated with a silylating reagent and measured by gas chromatography/mass spectrometry.
Similar content being viewed by others
References
Barnes, JR, Henry NW III (1974) The determination of N-methylformamide and N-methylacetamide in urine. Am Ind Hyg Assoc J 35:84–87
Bauer G, Wogt W (1981) Gas chromatographic determination of acids derived from phosphorus by trimethylsylation with N,O-bis(trimethylsilyl) trifluoro-acetamide in mice. Anal Chem 53:917–919
Brindley C, Gescher A, Ress D (1983) Studies of the metabolism of dimethylformamide in mice. Chem Biol Interact 45:387–392
Casal-Lareo A, Perbellini L (1995) Biological monitoring of workers exposed to N,N-dimethylformamide. II. Dimethylformamide and its metabolites in urine of exposed workers. Int Arch Occup Environ Health 67:47–52
Catenacci G, Ghittori S, Cottica D, Prestinoni A, Capodaglio E (1980) Occupational exposure to dimethylformamide and urinary excretion of monomethylformamide. G Ital Med Lav 2:53–57
Kawai T, Tomojiro Y, Takao W, Cai S-X, Mei-Yuan H, LiQiang X, Jiang-Bin Q, Bang-Zong Y, Ikeda M (1992) Occupational dimethylformamideexposure. 2. Monomethyl-formamide excretion in urine after occupational dimethyl-formamide exposure. Int Arch Occup Environ Health 63:455–460
Kimmerle G, Eben A (1975) Metabolism studies of N,Ndimethyl formamide. I. Studies in rats and dogs. Int Arch Arbeitsmed 34:109–126
Kimmerle G, Eben A (1975) Metabolism studies of N,Ndimethyl formamide. II. Studies in persons. Int Arch Arbeitsmed 34:127–136
Krivanek ND, McLaughlin M, Fayerweather WE (1978) Monomethyl formamide levels in human urine after repetitive exposure to dimethylformamide vapor. J Occup Med 20:179–182
Lauwerys R, Kivits A, Lhoir M, Rigolet P, Houbeau D, Buchet JP, Roels HA (1980) Biological surveillance of workers exposed to dimethylformamide and the influence of skin protection on its percutaneous absorption. Int Arch Occup Environ Health 45:189–203.
Maxfield ME, Barnes JR, Azar A, Trochimowicz MT (1975) Urinary excretion of metabolites following experimental human exposures to DMF or to DMAC. J Occup Med 17:506–511
Mraz J (1988) Gas chromatographic method for the determination of N-acetyl-S-(N-methylcarbamoyl)-cysteine, a metabolite of N,N-dimethyl formamide and N-methylformamide, in human urine. J Chromatogr Biomed Appl 431:361–368
Mraz J, Cross H, Gescher A, Threadgill MD, Flek J (1989) Differences between rodents and humans in the metabolic toxification of N,N-dimethylformamide. Toxicol Appl Pharmacol 98:507–516
Mraz J, Nohova H (1992) Absorption, metabolism and elimination of N,N-dimethylformamide in humans. Int Arch Occup Environ Health 64:85–92
Mraz J, Nohova H (1992) Percutaneous absorption of N,Ndimethyl formamide in humans. Int Arch Occup Environ Health 64:79–83
Mraz J, Turecek F (1987) Identification of N-acetyl-S-(N-methylcarbamoyl)-cysteine, a human metabolite of N,N-dimethyl-formamide. J Chromatogr Biomed Appl 414:399–404
Pozzoli L, Cottica D, Ghittori S, Catenacci G (1981) Monitoring of occupational exposure to dimethylformamide by passive personal samplers and monomethylformamide urinary excretion. G Ital Med Lav 3:161–163
Sala C, Bernabeo F, Colombo G, Invernizzi E, Meneghel G (1984) Dimethylformamide risk. An evaluation in the production of artificial organic leather. G Ital Med Lav 6:143–148
Santoni G, Bavazzano P, Perico A, Colzi A, Benassi S, Medica A, La Morgia R, Giuliano G (1992) High-performance liquid chromatography determination of N-methylformamide and N-methyl-(hydroxymethyl)formamide in human urine. J Chromatogr Biomed Appl 581:287–292
Scailteur V, De Hoffman E, Buchet JP, Lauwerys R (1984) Study on in vivo and in vitro metabolism of dimethylformamide in male and female rats. Toxicology 29:221–234
Scailteur V, Lauwerys R (1984) In vivo metabolism of dimethylformamide and its relationship to toxicity in the male rat. Arch Toxicol 56:87–91
Yonemoto J, Suzuki S (1980) Relation of exposure to dimethylformamide vapor and the metabolite, methylformamide in urine of workers. Int Arch Occup Environ Health 45:159–165
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Casal Lareo, A., Perico, A., Bavazzano, P. et al. Biological monitoring of workers exposed to N, N-dimethylformamide. Int. Arch Occup Environ Heath 67, 41–46 (1995). https://doi.org/10.1007/BF00383131
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF00383131