Abstract
As technology has advanced, electronic components and systems have become smaller and more powerful. A similar trend holds for space systems, and satellites are no exception. As payloads become smaller, so too can the launch vehicles designed to carry them into orbital trajectories. An energy analysis shows that a rocket system with as low as tens of kg of fuel can be sufficient to deliver a 10g payload into orbit given a sufficiently low mass autonomous rocket flight control system. To develop this, the GINA board, a 2g sensor-laden wireless-enabled microprocessor system, was mounted on a custom actuated rocket system and programmed for inertial flight control. Ground and flight tests demonstrated accurate dead reckoning state estimation along with successful open loop actuator control. Further experiments showed the capabilities of the control system at closed loop feedback control. The results presented in this paper demonstrate the feasibility of a sufficiently low mass flight controller, paving the way for a small scale rocket system to deliver a 10g attosatellite into low Earth orbit (LEO).
This is a preview of subscription content, log in via an institution to check access.
Access this chapter
Tax calculation will be finalised at checkout
Purchases are for personal use only
Preview
Unable to display preview. Download preview PDF.
References
Hitt, D.L., et al.: Mems-based satellite micropropulsion via catalyzed hydrogen peroxide decomposition. Smart Materials and Structures 10(6), 1163–1175 (2001)
Vladimirova, T., et al.: Characterising wireless sensor motes for space applications. In: Second NASA/ESA Conference on Adaptive Hardware and Systems, pp. 43–50 (August 2007)
Barnhart, D.J., et al.: A low-cost femtosatellite to enable distributed space missions. Acta Astronautica 64(11), 1123–1143 (2009)
Janson, S.: Micro/Nanotechnology for Micro/Nano/Picosatellites. In: SPACE Conferences & Exposition. American Institute of Aeronautics and Astronautics (September 2003)
Kramer, H.J., Cracknell, A.P.: An overview of small satellites in remote sensing. International Journal of Remote Sensing 29(15), 4285–4337 (2008)
Santacreu, E.B.: Study of a low cost inertial platfom for a femto-satellite deployed by a mini-launcher (2010)
Wertz, J.R.: Spacecraft attitude determination and control, vol. 73. Springer (1978)
Sarigul-Klijn, N., et al.: Air launching earth-to-orbit vehicles: Delta V gains from launch conditions and vehicle aerodynamics. In: 42nd AIAA Aero. Sci. Mtg. and Exhibit (January 2004)
Malina, F.J.: The problem of escape from the earth by rocket. Journal of the Aeronautical Sciences (Institute of the Aeronautical Sciences) 14(8) (2012)
Tsohas, J., et al.: Sounding rocket technology demonstration for small satellite launch vehicle project. In: AIAA 4th Responsive Space Conference, Los Angeles, CA, pp. 1–15 (2006)
Ransone, E.D., Gregory, D.D.: An overview of the NASA sounding rockets and balloon programs. In: 17th ESA Symposium on European Rocket and Balloon Programmes and Related Research, vol. 590, pp. 19–24 (2005)
Kanevsky, V., Ventskovsky, O.: Gun launch system for small satellites: A fresh look. In: Small Satellites for Earth Observation: Selected Proc. of the 5th Int’l. Symp. of the Int’l. Academy of Astronautics, Berlin, April 4-8, p. 214 (2005)
Toorian, A., Diaz, K., Lee, S.: The cubesat approach to space access. In: 2008 IEEE Aerospace Conference, pp. 1–14 (2008)
Rainwater, E.L., Smith, M.S.: Ultra high altitude balloons for medium-to-large payloads. Advances in Space Research 33, 1648–1652 (2004)
Van Allen, J.A.: Balloon-Launched Rockets for High-Altitude Research, ch. 9 (1959)
Gizinski, S.J., Wanagas, J.D.: Small satellite delivery using a balloon-based launch system. In: International Communication Satellite Systems Conference and Exhibit (March 1992)
Nakka, R.A.: Solid Propellant Rocket Motor Design and Testing. U. Manitoba (1984)
Jove-Casulleras, R., Tristancho, J., Vera-Flores, C.: Technical Constraints for a Low-Cost Femto-Satellite Launcher. AIAA Aero. Sci. Mtg. (January 2011)
Tsien, H.S.: Optimum thrust programming for a sounding rocket. Journal of the American Rocket Society 21(5), 99–107 (1951)
Ghersin, A.S., Pena, R.S.S.: Lpv control of a 6-dof vehicle. IEEE Transactions on Control Systems Technology 10(6), 883–887 (2002)
Eldridge, A.M.: Improved State Estimation for Miniature Air Vehicles. Master’s thesis, Brigham Young University (2006)
Gemeiner, P., Einramhof, P., Vincze, M.: Simultaneous Motion and Structure Estimation by Fusion of Inertial and Vision Data. The International Journal of Robotics Research 26(6), 591–605 (2007)
Montenbruck, O., Markgraf, M.: A gps tracking system with onboard iip prediction for sounding rockets. Journal of Spacecraft and Rockets 41, 644–650 (2003)
Izquierdo, L., Tristancho, J.: Next generation of sensors for femto-satellites based on commercial-of-the-shelf. In: 2011 IEEE/AIAA 30th Digital Avionics Systems Conference (DASC), p. 8A4-1. IEEE (2011)
Mehta, A.M., Pister, K.S.J.: Warpwing: A complete open source control platform for miniature robots. In: IROS, pp. 5169–5174. IEEE (2010)
National association of rocketry: NAR certified motors, http://www.nar.org/SandT/NARenglist.shtml (updated June 03, 2009, accessed September 15, 2009)
Author information
Authors and Affiliations
Corresponding author
Editor information
Editors and Affiliations
Rights and permissions
Copyright information
© 2015 Springer International Publishing Switzerland
About this chapter
Cite this chapter
Kehl, F., Mehta, A.M., Pister, K.S.J. (2015). An Attitude Controller for Small Scale Rockets. In: Mejias, L., Corke, P., Roberts, J. (eds) Field and Service Robotics. Springer Tracts in Advanced Robotics, vol 105. Springer, Cham. https://doi.org/10.1007/978-3-319-07488-7_14
Download citation
DOI: https://doi.org/10.1007/978-3-319-07488-7_14
Publisher Name: Springer, Cham
Print ISBN: 978-3-319-07487-0
Online ISBN: 978-3-319-07488-7
eBook Packages: EngineeringEngineering (R0)