Skip to main content

Advertisement

SpringerLink
Log in

Application of supplementary white and pulsed light-emitting diodes to lettuce grown in a plant factory with artificial lighting

  • Research Report
  • Protected Horticulture
  • Published:
Horticulture, Environment, and Biotechnology Aims and scope Submit manuscript

Abstract

Light-emitting diodes (LEDs) are currently undergoing rapid development as plant growth light sources in a plant factory with artificial lighting (PFAL). However, little is known about the effects of supplementary light and pulsed LEDs on plant growth, bioactive compound productions, and energy efficiency in lettuce. In this study, we aimed to determine the effects of supplementary white LEDs (study I) and pulsed LEDs (study II) on red leaf lettuce (Lactuca sativa L. ‘Sunmang’). In study I, six LED sources were used to determine the effects of supplementary white LEDs (RGB 7:1:1, 7:1:2, RWB 7:1:2, 7:2:1, 8:1:1, 8:2:0 [based on chip number] on lettuce). Fluorescent lamps were used as the control. In study II, pulsed RWB 7:2:1 LED treatments (30, 10, 1 kHz with a 50 or 75% duty ratio) were applied to lettuce. In study I, the application of red and blue fractions improved plant growth characteristics and the accumulation of antioxidant phenolic compounds, respectively. In addition, the application of green light increased plant growth, including the fresh and dry weights of shoots and roots, as well as leaf area. However, the substitution of green LEDs with white LEDs induced approximately 3.4-times higher light and energy use efficiency. In study II, the growth characteristics and photosynthesis of lettuce were affected by various combinations of duty ratio and frequency. In particular, biomass under a 1 kHz 75% duty ratio of pulsed LEDs was not significantly different from that of the control (continuous LEDs). Moreover, no significant difference in leaf photosynthetic rate was observed between any pulsed LED treatment utilizing a 75% duty ratio versus continuous LEDs. However, some pulsed LED treatments may potentially improve light and energy use efficiency compared to continuous LEDs. These results suggest that the fraction of red, blue, and green wavelengths of LEDs is an important factor for plant growth and the biosynthesis of bioactive compounds in lettuce and that supplementary white LEDs (based on a combination of red and blue LEDs) might be more suitable as a commercial lighting source than green LEDs. In addition, the use of suitable pulses of LEDs might save energy while inducing plant growth similar to that under continuous LEDs. Our findings provide important basic information for designing optimal light sources for use in a PFAL.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

Literature Cited

  • Ainsworth EA, Gillespie KM (2007) Estimation of total phenolic content and other oxidation substrates in plant tissues using Folin-Ciocalteu reagent. Nat Protoc 2:875–877

    Article  CAS  PubMed  Google Scholar 

  • Banaś AK, Aggarwal C, Łabuz J, Sztatelman O, Gabryś H (2012) Blue light signaling in chloroplast movements. J Exp Bot 63:1559–1574

    Article  PubMed  Google Scholar 

  • Bula RJ, Tibbitts TW, Morrow RC, Dinauer WR (1992) Commercial involvement in the development of space-based plant growing technology. Adv Space Res 12:5–10

    Article  CAS  PubMed  Google Scholar 

  • Carvalho RF, Takaki M, Azevedo RA (2011) Plant pigments: the many face of light perception. Acta Physiol Plant 33:241–248

    Article  CAS  Google Scholar 

  • Chang MH, Das D, Varde PV, Pecht M (2012) Light emitting diodes reliability review. Microelectron Reliab 52:762–782

    Article  Google Scholar 

  • Cope KR, Bugbee B (2013) Spectral effects of three types of white light-emitting diodes on plant growth and development: absolute versus relative amounts of blue light. HortScience 48:504–509

    CAS  Google Scholar 

  • Dewanto V, Wu X, Adom KK, Liu RH (2002) Thermal processing enhances the nutritional value of tomatoes by increasing total antioxidant activity. J Agric Food Chem 50:3010–3014

    Article  CAS  PubMed  Google Scholar 

  • Dong C, Fu Y, Liu G, Liu H (2014) Growth, photosynthetic characteristics, antioxidant capacity and biomass yield and quality of wheat (Triticum aestivum L.) exposed to LED light sources with different spectra combinations. J Agron Crop Sci 200:219–230

    Article  CAS  Google Scholar 

  • Dong C, Shao L, Liu G, Wang M, Liu H, Xie B, Li B, Fu Y, Liu H (2015) Photosynthetic characteristics, antioxidant capacity and biomass yield of wheat exposed to intermittent light irradiation with millisecond-scale periods. J Plant Physiol 184:28–36

    Article  CAS  PubMed  Google Scholar 

  • Ebisawa M, Shoji K, Kato M, Shimomura K, Goto F, Yoshihara T (2008) Supplementary ultraviolet radiation B together with blue light at night increased quercetin content and-avonol synthase gene expression in leaf lettuce (Lactuca sativa L.). Environ Control Biol 46:1–11

    Article  CAS  Google Scholar 

  • Folta KM, Maruhnich SA (2007) Green light: a signal to slow down or stop. J Exp Bot 58:3099–3111

    Article  CAS  PubMed  Google Scholar 

  • Fu W, Li P, Wu Y (2012) Effects of different light intensities on chlorophyll-uorescence characteristics and yield in lettuce. Sci Hortic 135:45–51

    Article  CAS  Google Scholar 

  • Hashimoto Y, Yi Y, Nyunoya F, Anzai Y, Yamazaki H, Nakayama S, Ikeda A (1987) Vegetable growth as affected by on-off light intensity developed for vegetable factory. Acta Hortic 229:259–264

    Google Scholar 

  • Hogewoning SW, Trouwborst G, Maljaars H, Poorter H, van Ieperen H, Harbinson J (2010) Blue light dose-responses of leaf photosynthesis, morphology, and chemical composition of Cucumis sativus grown under different combinations of red and blue light. J Exp Bot 61:3107–3117

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  • Jao RC, Fang W (2004) Effect of frequency and duty ratio on the growth of potato plantlets in vitro using light-emitting diodes. HortScience 39:375–379

    Google Scholar 

  • Jishi T, Fujiwara K, Nishino K, Yano A (2011) Pulsed light at lower duty ratios with lower frequencies is disadvantageous for CO2 uptake in cos lettuce compared to continuous light. In Proceedings of 4th Lighting Conference of China, Japan and Korea; 2011 Sep 22-24; Ealian, China; 321–324

    Google Scholar 

  • Jishi T, Matsuda R, Fujiwara K (2015) A kinetic model for estimating net photosynthetic rates of cos lettuce leaves under pulsed light. Photosynth Res 124:107–116

    Article  CAS  PubMed  Google Scholar 

  • Johkan M, Shoji K, Goto F, Hashida S, Yoshihara T (2010) Blue light-emitting diode light irradiation of seedlings improves seedling quality and growth after transplanting in red leaf lettuce. HortScience 45:1809–1814

    Google Scholar 

  • Johkan M, Shoji K, Goto F, Hahida S, Yoshihara T (2012) Effect of green light wavelength and intensity on photomorphogenesis and photosynthesis in Lactuca sativa. Environ Exp Bot 75:128–133

    Article  CAS  Google Scholar 

  • Kim HH, Wheeler R, Sager JC, Yorio N, Goins G (2005) Light-emitting diodes as an illumination source for plants: A review of research at Kennedy Space Center. Habitat (Elmsford) 10:71–78

    Article  Google Scholar 

  • Kumagai E, Araki T, Kubota F (2009) Correlation of chlorophyll meter readings with gas exchange and chlorophyll fluorescence in flag leaves of rice (Oryza sativa L.) plants. Plant Prod Sci 12:50–53

    Article  Google Scholar 

  • Loo KH, Lun WK, Tan SC, Lai YM, Tse CK (2009) On driving techniques for LEDs: toward a generalized methodology. IEEE Trans on Power Electron 24:2967–2976

    Article  Google Scholar 

  • Matsuda R, Ohashi-Kaneko K, Fujiwara K, Kurata K (2007) Analysis of the relationship between blue-light photon flux density and the photosynthetic properties of spinach (Spinacia oleracea L.) leaves with regard to the acclimation of photosynthesis to growth irradiance. Soil Sci Plant Nutr 53:459–465

    Article  CAS  Google Scholar 

  • McCree KJ (1972) Action spectrum, absorptance and quantum yield of photosynthesis in crop plants. Agric Meteorol 9:191–216

    Article  Google Scholar 

  • Miller NJ, Rice-Evans CA (1996) Spectrophotometric determination of antioxidant activity. Redox Rpt 2:161–171

    Article  CAS  Google Scholar 

  • Olvera-Gonzalez E, Alaniz-Lumbreras D, Ivanov-Tsonchev R, Villa-Hernández J, Olvera-Olvera C, González-Ramírez E, Castaño V (2013a) Intelligent lighting system for plant growth and development. Comput Electron Agric 92:48–53

    Article  Google Scholar 

  • Olvera-González E, Alaniz-Lumbreras D, Ivanov-Tsonchev R, Villa-Hernández J, de la Rosa-Vargas I, López-Cruz I, Lara-Herrera A (2013b) Chlorophyll fluorescence emission of tomato plants as a response to pulsed light based LEDs. Plant Growth Regul 69:117–123

    Article  Google Scholar 

  • Ouzounis T, Parjikolaei BR, Fretté X, Rosenqvist E, Ottosen CO (2015) Predawn and high intensity application of supplemental blue light decreases the quantum yield of PSII and enhances the amount of phenolic acids, flavonoids, and pigments in Lactuca sativa. Front Plant Sci 6:19. doi: 0.3389/fpls.2015.00019

    Article  PubMed  PubMed Central  Google Scholar 

  • Park JE, Park YG, Jeong BR, Hwang SJ (2012) Growth and anthocyanin content of lettuce as affected by artificial light source and photoperiod in a closed-type plant production systemplant factory with artificial lighting. Korean J Hortic Sci Technol 30:673–679

    Article  CAS  Google Scholar 

  • Pimputkar S, Speck JS, DenBaars SP, Nakamura S (2009) Prospects for LED lighting. Nat Photonics 3:180–182

    Article  CAS  Google Scholar 

  • Piovene C, Orsini F, Bosi S, Sanoubar R, Bregola V, Dinelli G, Gianquinto G (2015) Optimal red: blue ratio in led lighting for nutraceutical indoor horticulture. Sci Hortic 193:202–208

    Article  Google Scholar 

  • Rajashekar CB, Carey EE, Zhao X, Oh MM (2009) Health-promoting phytochemicals in fruits and vegetables: Impact of abiotic stresses and crop production practices. Funct Plant Sci Biotechnol 3:30–38

    Google Scholar 

  • Saebo A, Krekling T, Appelgren M (1995) Light quality affects photosynthesis and leaf anatomy of birch plantlets in vitro. Plant Cell Tissue Organ Cult 41:177–185

    Article  Google Scholar 

  • Sager JC, Giger W (1980) Re-evaluation of published data on the relative photosynthetic efficiency of intermittent and continuous light. Agric Meteorol 22:289–302

    Article  Google Scholar 

  • Savvides A, Fanourakis D, van Leperen W (2012) Co-ordination of hydraulic and stomatal conductances across light qualities in cucumber leaves. J Exp Bot 63:1135–1143

    Article  CAS  PubMed  Google Scholar 

  • Shimada A, Taniguchi Y (2011) Red and blue pulse timing control for pulse width modulation light dimming of light emitting diodes for plant cultivation. J. Photochem Photobiol B: Biol 104:399–404

    Article  CAS  Google Scholar 

  • Smith EL (1936) Photosynthesis in relation to light and carbon dioxide. Proc Natl Acad Sci 22:504–511

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  • Son KH, Park JH, Kim D, Oh MM (2012) Leaf shape, growth, and phytochemicals in two leaf lettuce cultivars grown under monochromatic light-emitting diodes. Korean J Hortic Sci Technol 30:664–672

    Article  CAS  Google Scholar 

  • Son KH, Oh MM (2013) Leaf shape, growth, and antioxidant phenolic compounds of two lettuce cultivars grown under various combinations of blue and red light-emitting diodes. HortScience 48:988–995

    Google Scholar 

  • Son KH, Oh MM (2015) Growth, photosynthetic and antioxidant parameters of two lettuce cultivars as affected by red, green, and blue light-emitting diodes. Hortic Environ Biotechnol 56:639–653

    Article  CAS  Google Scholar 

  • Stutte GW (2015) Commercial transition to LEDs: A pathway to high-value products. HortScience 50:1297–1300

    Google Scholar 

  • Stutte GW, Edney S, Skerritt T (2009) Photoregulation of bioprotectant content of red leaf lettuce with light-emitting diodes. HortScience 44:79–82

    Google Scholar 

  • Taiz L, Zeiger E (1991) Plant physiology. 1 st ed., 179–264. Benjamin/Cummings Publishing Co. New York

    Google Scholar 

  • Tamulaitis G, Duchovskis P, Bliznikas Z, Breive K, Ulinskaite R, Brazaityte A, Novickovas A, Zukauskas A (2005) High-power light-emitting diode based facility for plant cultivation. J Phys D Appl Phys 38:293–3187

    Article  Google Scholar 

  • Yoneda K, Mori Y (2004) Method of cultivating plant and illuminator for cultivating plant. European Patent Of-ce EP1374665A1

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Division of Animal, Horticultural and Food Sciences, Chungbuk National University, Cheongju, 28644, Korea

    Ki-Ho Son, Yu-Min Jeon & Myung-Min Oh

  2. Brain Korea 21 Center for Bio-Resource Development, Chungbuk National University, Cheongju, 28644, Korea

    Ki-Ho Son, Yu-Min Jeon & Myung-Min Oh

Authors
  1. Ki-Ho Son
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Yu-Min Jeon
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Myung-Min Oh
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Myung-Min Oh.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Son, KH., Jeon, YM. & Oh, MM. Application of supplementary white and pulsed light-emitting diodes to lettuce grown in a plant factory with artificial lighting. Hortic. Environ. Biotechnol. 57, 560–572 (2016). https://doi.org/10.1007/s13580-016-0068-y

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13580-016-0068-y

Additional key words

Search

Navigation